LEMON Manuals: Even more car manuals for everyone
Home >> Volvo >> 2008 >> S40 T-5, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 79 (Rear Axle, Drive Shafts - Removal, Replacement And Installation (644 Body)) >> Replacing Drive Shafts/Boots (Aw50-42; 2000) >> Drive shaft right-hand side, replacing >> Installation >> Installing the drive shaft

Installing the drive shaft

WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Checking Drive Shafts
GLL102155Courtesy of VOLVO CARS OF NORTH AMERICA.

Remove the seal plug.

Install the drive shaft in the transmission.

CAUTION: Take care not to damage the boot and sealing ring in the transmission. Press in the drive shaft properly. Check that the drive shaft is locked into place in the differential drive: Pull the drive shaft constant velocity joint carefully.
scientia non olet · About LEMON Manuals