Checking the signal cable

WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: Identifying Ignition OFF

Courtesy of VOLVO CARS OF NORTH AMERICA.

Ignition off.
Check the cable between turbocharger (TC) control valve connector terminal 2 and engine control module (ECM) connector terminal #5. Check for an open-circuit according to Open-circuit, permanent faults .

Remedy as necessary.

Fig 2: Identifying Injector Connector Terminals
Courtesy of VOLVO CARS OF NORTH AMERICA.

Fig 3: Identifying Ohmmeter
Courtesy of VOLVO CARS OF NORTH AMERICA.

Fig 4: Identifying EMS2000
Courtesy of VOLVO CARS OF NORTH AMERICA.

Continue
Refer to Verification

Fig 1: Identifying Ignition OFF

Courtesy of VOLVO CARS OF NORTH AMERICA.

Ignition off.
Check the cable between turbocharger (TC) control valve connector terminal 1 and system relay 2/14 terminal 3. Check for an open-circuit according to Open-circuit, permanent faults .

Remedy as necessary.

Fig 2: Identifying Injector Connector Terminals
Courtesy of VOLVO CARS OF NORTH AMERICA.

Fig 3: Identifying Ohmmeter
Courtesy of VOLVO CARS OF NORTH AMERICA.

Fig 4: Identifying System Relay Base Terminals
Courtesy of VOLVO CARS OF NORTH AMERICA.

Continue
Refer to Verification