Section 121 (Headlining & Interior Panels - Removal & Installation (644 Body))
WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.
- Exterior/Interior Trim
- C-post panel
- D-post panel
- Dashboard, replacing
- Removing dashboard assembly
- Removing the panels under the dashboard
- Removing the instrument panel
- Removing the odometer cable and wiring from the dashboard
- Removing the loudspeakers from the dashboard
- Removing the control panel for the heater system
- Removing the dashboard bracket
- Disconnecting the control cable to the "airmix" at the end pointed towards the heater
- Disconnecting the wiring and the hood latch
- Remove the rear center console
- Detaching the front center console
- Removing the dashboard
- Headlining, replacing (2001-2004)
- Headlining, replacing (2000)
- Replacing the headlining
- Removing the A-post panels
- Removing the front interior lighting
- Removing the ultrasonic sensor (alarm)
- Removing the sun visor and holder
- Removing the grab handle
- Removing the rear reading lamps or lenses
- Removing the B-post panels
- Removing the rear interior lighting, 5 door models
- Removing the C-post panels
- Removing the D-post panels, 5-door models
- Removing the cover for the high-mounted stop lamp, 4 door models
- Removing the headlining
- Panels and consoles
- Removing the rear center console
- Removing the side panel from the center console
- Removing the front center console
- Replacing the inner panel on the A-post
- Replacing the inner panel on the B-post
- Replacing the inner panel on the C-post, 4-door cars
- Replacing the inner panel on the C-post, 5-door cars
- Replacing the inner panel on the D-post, 5-door cars
- Replacing the side panels in the cargo compartment, 4-door cars
- Replacing the side panels in the cargo compartment, 5-door cars
- Rear center console