LEMON Manuals: Even more car manuals for everyone
Home >> Volvo >> 2007 >> S60 T-5, Automatic >> Repair and Diagnosis >> External Pages >> Different car >> Section 1 (Brake Bleeding And Disc - General Specifications) >> Bleeding Brake System >> Manual Bleeding

Manual Bleeding

WARNING: This page does not describe the selected car, but rather 10 other vehicles, including the 2004 Volvo S80, 2004 Volvo S60, 2003 Volvo S80, 2003 Volvo S60, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: Before bleeding brakes, ensure ignition is off. Clean around brake fluid reservoir filler cap before removing. Top-off brake fluid reservoir as necessary.
NOTE: Use DOT 4 brake fluid.
  1. Raise and support vehicle.
  2. Remove protective cap from left front bleed nipple.
  3. Connect the hose from collection bottle.
  4. Depress brake pedal a few times. Maintain pressure.
  5. Open left front bleed nipple.
  6. Depress brake pedal fully. Keep it fully depressed for approximately 5 seconds. Release it again.
  7. Repeat this 3-5 times until there are no air bubbles in fluid coming out of hose.
  8. Tighten bleed nipple.
  9. Remove hose from bleed nipple. Install protective cap.
  10. Repeat procedure for right rear, left rear and right front brakes. See BRAKE BLEEDING SEQUENCE  table.
BRAKE BLEEDING SEQUENCE

Application Sequence
S60 & S80 LF, RF, LR & RR
scientia non olet · About LEMON Manuals