LEMON Manuals: Even more car manuals for everyone
Home >> Volvo >> 2004 >> S80 Base, 2.5 59, FWD >> Repair and Diagnosis >> Transmission >> Automatic Trans >> Engine And Transmission - Removal And Installation >> Engine Mechanical >> Engine/transmission, removing/installing >> Drive shaft left, replacing (M56 and M58 2000-) >> Remove the drive shaft from the transmission

Remove the drive shaft from the transmission

Fig 1: Identifying Left Drive Shaft From Gearbox & Jimmy Bar
GLL109814Courtesy of VOLVO CARS OF NORTH AMERICA.

Use jimmy tool 9995462 when removing the drive shaft.

NOTE:

Pull the constant velocity joint  , not the drive shaft joints, when removing the drive shaft. There is no axial pinion.

NOTE:

Take care not to damage the drive shaft when removing it from the transmission.

Fig 2: Identifying Rubber Seal & Constant Velocity Joint
GLL106610Courtesy of VOLVO CARS OF NORTH AMERICA.
CAUTION:

Later models have a rubber seal on the constant velocity joint. Do not damage the seal. It will be needed for installation.

scientia non olet · About LEMON Manuals