Draining the fuel tank: Preparation

WARNING: This page is about a different car, the 2002 Volvo C70, 2001 Volvo C70, 2000 Volvo C70, 1999 Volvo C70, and 1998 Volvo C70. However, it is still accessible from the selected car via links, so may be relevant.

Disconnect the battery negative lead. See Battery, disconnecting

WARNING:

RISK OF EXPLOSION THE USE OF A FRESH AIR MASK IS RECOMMENDED.

Insert the heavy duty hose 1.3 meters into the fuel filler pipe, measured from the edge of the opening of the filler pipe.

Pump until air comes out.

Fig 1: Identifying Screw And Connector At Seat Hinge

Courtesy of VOLVO CARS OF NORTH AMERICA.

(V70) Fold up both sides of the rear seat.

(S80, S60) Remove the seat cushion for the rear seat.

Remove the right side cushion. See Side cushion

Disconnect the connector at the hinge.

Remove:

the mounting screw for the hinge
the screw for the seatbelt end mounting.

Release the strap/straps of the folding mechanism for the seat belt buckle. (Hooked into place on the lower edge of the backrest).

Lift out the backrest.

Fig 2: Pushing Carpet Aside And Identifying Area Around Fuel Pump Cover

Courtesy of VOLVO CARS OF NORTH AMERICA.

Fold the carpet (1) out of the way.

Remove the insulation panel.

Cover the area (2) around the cover and between the doors with absorbent material.

CAUTION:

Ensure that there is no risk of dirt getting into the tank.