Safety equipment: Notes

WARNING: This page is about a different car, the 2002 Volvo C70, 2001 Volvo C70, 2000 Volvo C70, 1999 Volvo C70, and 1998 Volvo C70. However, it is still accessible from the selected car via links, so may be relevant.

1. Steering wheel module

Fig 1: Identifying Steering Wheel Module

Courtesy of VOLVO CARS OF NORTH AMERICA.

The steering wheel module is unlocked in two stages.

When working on the steering wheel, steering shaft or steering gear, certain operations must be carried out according to the methods for working on the steering wheel module.

2. Passenger module

Fig 2: Identifying Passenger Airbag Module

Courtesy of VOLVO CARS OF NORTH AMERICA.

The passenger airbag module is unlocked in two stages.

3a - c SIPS module (Side Impact Protection System)

Fig 3: Locating Side Airbags

Courtesy of VOLVO CARS OF NORTH AMERICA.

3a. There are side airbags in both the front seats.

3b. The sensors are located in the B and C-posts.

3c. The sensors are located in the B posts.

Fig 4: Locating Sensors In B And C-Posts

Courtesy of VOLVO CARS OF NORTH AMERICA.

Fig 5: Locating Sensors In B Posts

Courtesy of VOLVO CARS OF NORTH AMERICA.

4a - e Seat belts and seat belt tensioners

Fig 6: Locating Seat Belt Tensioners

Courtesy of VOLVO CARS OF NORTH AMERICA.

NOTE:

The following models have pyrotechnical seat belt tensioners:

850 1994 -

S/V 70 Front

S/V 40 Front

All seat belts are equipped with pyrotechnical seat belt tensioners.

Fig 7: Identifying Pyrotechnical Seat Belt Tensioners

Courtesy of VOLVO CARS OF NORTH AMERICA.

Fig 8: Identifying Rear Seat Belts

Courtesy of VOLVO CARS OF NORTH AMERICA.

Fig 9: Identifying Front Seat Belt (Inertia) Reel

Courtesy of VOLVO CARS OF NORTH AMERICA.

Fig 10: Identifying Rear Seat Belt (Inertia) Reel

Courtesy of VOLVO CARS OF NORTH AMERICA.

5a. IC, Inflatable Curtain

Fig 11: Identifying Inflatable Curtain

Courtesy of VOLVO CARS OF NORTH AMERICA.

The curtain consists of two inflatable protective curtains located in the edges of the roof on each side of the car.

The curtain shields the upper section of the car interior, from the A to the C-posts.

Fig 12: Locating Curtain Shields On Upper Section Of Car Interior

Courtesy of VOLVO CARS OF NORTH AMERICA.

6. WHIPS (Whiplash Protection System)

Fig 13: Identifying Whiplash Protection Mechanism

Courtesy of VOLVO CARS OF NORTH AMERICA.

Applies to all car models from 1999- inclusive

The front seats have the WHIPS function. The aim of WHIPS is to minimize the risk of whiplash injuries in the event of a collision.

The system is completely mechanical and is integrated into the seats.

7. SRS control module

Fig 14: Identifying SRS Control Module

Courtesy of VOLVO CARS OF NORTH AMERICA.

NOTE:

Never install car accessories on or near the SRS control module.

The SRS control module is located between the parking brake and the gear selector lever in the center console.

8a - b ROPS module (Roll Over Protection System)

Fig 15: Identifying Roll Over Protection System (1 Of 2)

Courtesy of VOLVO CARS OF NORTH AMERICA.

ROPS is a mechanical safety system where two roll-over bars deploy automatically if the car rolls over. These are located behind the rear head restraints.

Fig 16: Identifying Roll Over Protection System (2 Of 2)

Courtesy of VOLVO CARS OF NORTH AMERICA.