Install transmission
WARNING: This page is about a different car, the 2002 Volvo C70, 2001 Volvo C70, 2000 Volvo C70, 1999 Volvo C70, and 1998 Volvo C70. However, it is still accessible from the selected car via links, so may be relevant.
Install.
- Transmission.
See Installing the transmission .
Service Manual: Section 4 (41, 43, 46), Manual transmission M56, including clutch and drive shafts 850, 1992-.
Operations E1 to E20.
CAUTION:
Changes to method in operation E21 as follows:
Install.
- Wiring. Clamp cable trunks and ground lead.
- Install new quick-release connector on clutch line terminal.
- Lubricate rubber seal with a drop brake fluid before joining.
CAUTION:
Ensure everything is clean when working with hydraulic components.
- Check that striker plate is located in adapter.
Then secure clutch line in adapter so that striker plate clicks into place.
- Install clutch line in holder on side of transmission as illustrated above.
- Remove hose clip from hose in clutch master cylinder.
- Bleed system and fill brake fluid if required.
Use Volvo Genuine parts brake fluid only.
Now continue with operations E22 to E25.