LEMON Manuals: Even more car manuals for everyone
Home >> Volvo >> 2003 >> C70 2.3 53, Automatic >> Repair and Diagnosis >> External Pages >> Different car >> Section 171 (Steering Column, Steering Pump - Removal & Installation (Coupe)) >> Steering >> Steering Column/Shaft/Seal/Bearing/Joint, Replacing >> Steering column/shaft/seal/bearing/lower shaft universal joint, Replacing (Cars without SRS) >> Installation >> Install the steering shaft gaiter

Install the steering shaft gaiter

WARNING: This page is about a different car, the 2002 Volvo C70, 2001 Volvo C70, 2000 Volvo C70, 1999 Volvo C70, and 1998 Volvo C70. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Identifying Steering Shaft Boot And Needle Bearing
GLL126721Courtesy of VOLVO CARS OF NORTH AMERICA.

Lubricate the needle bearing in the gaiter with low-temperature grease part number 1161417-9  (30 grams).

Fold back the outer part of the gaiter.

Lubricate the edge on the inside of the inner part of the gaiter with soapy water.

Fit the inner part of the gaiter around the sheet metal collar in the bulkhead plate so that it seals tight all the way around 

Fig 2: Identifying Steering Shaft Rubber Grommet
GLL102216Courtesy of VOLVO CARS OF NORTH AMERICA.

Lubricate the inside of the lock ring with soapy water 

Fig 3: Identifying Inner Side Of Locking Ring
GLL126722Courtesy of VOLVO CARS OF NORTH AMERICA.

Press the lock ring into position around the inner part of the gaiter against the bulkhead plate. The outer part of the gaiter shall be folded back 

Fold down the outer part of the gaiter against the lock ring's flange. Make sure that it has contact all the way around.

Fig 4: Identifying Upper Section Of Boot And Locking Ring Flange
GLL126723Courtesy of VOLVO CARS OF NORTH AMERICA.

Make sure that the splines on the steering shaft are clean.

Lubricate the steering shaft's splines and the steering column's bearing with low-temperature grease, part number 1161417-9  (30 grams).