LEMON Manuals: Even more car manuals for everyone
Home >> Volvo >> 2002 >> S60 Base, 2.4 61, Standard >> Repair and Diagnosis >> Transmission >> Manual Trans >> Transmission - Removal, Replacement And Installation - 2 Of 2 >> Transmission, Manual (B5204T5, M56; 2004-2007) >> Input Shaft Seal >> Removal >> Removing the clutch cylinder

Removing the clutch cylinder

Fig 1: Identifying Clutch Cylinder
GLL109088Courtesy of VOLVO CARS OF NORTH AMERICA.

Remove the rubber seal from the clutch cover. Move it inwards on the pipe towards the clutch cylinder.

Pull out the retaining clip locking the quick-release connector on the pipe to the junction.

Remove the adapter. Keep it in a plastic bag to prevent contamination. Install a protective plug in the end of the pipe.

Remove the clutch cylinder.

Clean the mating surfaces in the clutch cover. Check any leakage from the gearbox.