Stock Maintenance Checklist - All Models. Interval 30 - 180 days
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
| Model/Chassis # | - | - | - | - | - | - | - | - | - | - | Location |
| Production Date | - | - | / | - | - | Release Date: | - | - | / | - | - | / | - | - |
| Perform inspection in the order detailed below. Check in non-empty boxes upon completion of inspection (Ok/Not Ok ) | ||||||
| Legend: "Ok/Not Ok" = to be executed at interval/ "-" = Not to be executed at interval | ||||||
| Maintenance date from "Factory Complete": | - | - | - | - | - | - |
| Interval days: | 30 | 60 | 90 | 120 | 150 | 180 |
| Check Rapgard™/Brake protection condition and repair if necessary 1 | - | - | Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
| Check exterior cleanliness, wash if necessary. Check for damages, repair if necessary. | - | - | Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
| Check tire pressure (set to 330.20 kPa, 48.3 PSI). | - | Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
| Check Battery voltage with Volvo Battery Analyzer 3100/3200. Fill out battery card. Indicate Voltage | - | Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
Ok Not Ok |
| Check interior components for heat related failures and cleanliness | - | - | Ok Not Ok |
- | Ok Not Ok |
- |
| Check interior protections are in place. Correct if required |
- | - | Ok Not Ok |
- | Ok Not Ok |
- |
| Remove and replace Rapgard™. If Rapgard™ is not replaced, protect the vehicle by applying wax approved by Volvo, p/n 9510269. Ensure that the vehicle is washed when needed | - | - | - | - | - | - |
| Change engine oil and replace oil filter. Oil quality: A3, B3, B4, A5, B5
NOTE:
Reset the service reminder indicator
|
- | - | - | - | - | - |
| Change engine oil and replace oil filter. Oil quality: A1, B1, WSS-M2C913-B
NOTE:
Reset the service reminder indicator
|
- | - | - | - | - | Ok Not Ok |
| Brake rotor rustcleaning. Drive vehicle at low speed, 0.3 km/0.2 miles with brake application 5X. (5 sec. per application) | - | - | Ok Not Ok |
- | Ok Not Ok |
- |
| Undercarriage, engine inspection (Check for rust and corrosion) | - | - | - | - | - | Ok Not Ok |
| After 180 days, remove tape from inner front sill molding - driver side. | - | - | - | - | - | Ok Not Ok |
| Inspector initials/number: | - | - | - | - | - | - |
| 1) Use the following codes if repair is required for RAPGARD: H=hood, T=trunk, R=roof, M=mirror, D=door, B=bumper | ||||||