Fuel line

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: Identifying Quick-Release Connector

Courtesy of VOLVO CARS OF NORTH AMERICA.

Under the car

Release the quick-release connectors
Pull the pipe from the clip.

Fig 2: Moving Clips Aside To Remove Fuel Line Cover

Courtesy of VOLVO CARS OF NORTH AMERICA.

Move the clips to one side to remove the cover over the fuel line.

Fig 3: Identifying Oetiker Clamps

Courtesy of VOLVO CARS OF NORTH AMERICA.

Disconnect the hose.
NOTE: Use Oetiker pincers 3374 to slacken off and secure the Oetiker clamps.
Disconnect the quick-release connector at the tank.

In the car

Remove the rear seat cushion. See Cushion
Remove the insulation.

Fig 4: Identifying Quick-Release Connector & Fuel Hose

Courtesy of VOLVO CARS OF NORTH AMERICA.

Remove the 4 nuts and the inspection hatch
Pull the hose up from the tank and feed out the remaining section.