Removing The Three-Way Catalytic Converter (TWC) (All-Wheel Drive (AWD) Only)
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
Remove
- the nuts where the exhaust pipe divides downstream of the three-way catalytic converter (TWC)
- the screws securing the SIPS member to the bodywork.
Remove the brake pipe from the holders on the SIPS member.
Lift off the front exhaust pipe from the turbocharger (TC) and the rear system.
Lower and pull back the three-way catalytic converter (TWC) with the SIPS member.
NOTE:
The routing of the heated oxygen sensor's cable harness over brake pipe.