Removing The Insert From The Center Tunnel Console

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: 12 Volt Socket Cover And Screws

Courtesy of VOLVO CARS OF NORTH AMERICA.

Remove:

the cover over the 12 volt socket on the rear edge of the center console. Insert a weatherstrip knife in the lower edge and pry off
the 2 screws and the panel for the 12 volt socket
the screw holding the insert at the rear edge.

Fig 2: Bottom Insert Screw

Courtesy of VOLVO CARS OF NORTH AMERICA.

Fold up the armrest on the center console.

Remove the screw holding the insert at the bottom.

Pull the insert straight up.