Removing The Radio/Carphone

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.

Remove the dashboard environment panel. See Dashboard environment panel (including climate control module (CCM)), replacing .

Fig 1: Identifying Radio/Car Phone Removal

Courtesy of VOLVO CARS OF NORTH AMERICA.

Remove the radio/carphone:

Unscrew the two screws in the lower edge.

Fig 2: Holding Radio Unit In Same Position As When Installed In Vehicle (Tilted 15--20 Degrees)

Courtesy of VOLVO CARS OF NORTH AMERICA.

NOTE:

Reset the CD-mechanism to original position before replacing the unit.

Hold the radio unit in the same position as when installed in the vehicle (tilted 15-20°) as illustrated. See illustration (A).

Reset the CD mechanism by:

Switch on the ignition.
Disconnect the green connector from the radio/CD player. Wait 5 seconds
Reconnect the green connector to the radio/CD player. The CD player has been reset
Wait until no sound is heard from the CD mechanism.

Remove the cable harness.