Diagnostics check list
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
A copy of this diagnostics list must always be returned in a plastic pocket attached to the replaced transmission. Also send a copy to the importer and keep the original. All fields must be completed.
| Workshop/Dealer | RO-Number: | Date: | |||||
| Chassis number: | Model: | Model year: | Mileage: .................. O km O miles |
Transmission serial number | |||
| Customer complaint: | |||||||
| Note all diagnostic trouble codes for TCM (DTCs): | O No DTCs | ||||||
| Noise: O Yes O No |
Describe noise: O
Whining O
Rattling O
Grinding O Knocking O Squeaking O Other/description: |
||||||
| Gear shifting problem: O Yes O No | Throttle: O High O Low O None | Speed: km/h | |||||
| Slipping | Delays | Hard engagement | No shifting | Vibrates | Other / description: | ||
| P-R | O | O | O | O | O | ||
| P-D | O | O | O | O | O | ||
| D-R | O | O | O | O | O | ||
| R-D | O | O | O | O | O | ||
| Changing up | O | O | O | O | O | ||
| Changing down | O | O | O | O | O | ||
| Forward | O | O | O | O | O | ||
| Reverse | O | O | O | O | |||
| The problems occur: | O Cold | O Hot | O Always | O Intermittent | |||
| Condition of the oil: O Gray O Red O Brown O Black O Pink O Other/description: |
|||||||
| Oil level (measured at normal operating temperature): O Below normal O Above normal O Normal |
|||||||
| Oil leakage: O Yes O No | Oil leaking from: | ||||||
| Are there any signs of oil in the radiator or coolant in the oil? O No O Yes: Replace the radiator. |
|||||||
| Adjusting the gear selector Adjusting the park / neutral position (PNP) switch: |
O
Correct O
Faulty O Correct O Faulty |
||||||
|
NOTE:
When appropriate, move over the bracket for collision safety.
|
|||||||
| Comments/ Further information: | |||||||