Section 201 (Gearbox And Gearshift Position Sensor - Checking/Adjusting, Removal And Installation)
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
- Transmission
- Gearbox, removing
- Notes
- Gearbox, removing (AW55-50 -2000)
- Notes
- Preparatory work
- Removal
- Disconnecting the battery lead
- Removing engine compartment components
- Removing components from the gearbox
- Removing the gearbox mounting screws
- Removing the coolant hose from the passenger compartment heater
- Installing the lifting beam and lifting hook on the engine lifting eyelet
- Removing the air baffle and splash guard under the engine
- Removing the screw for the cable duct
- Removing the cross members from the body
- Removing the screws and nuts for the engine pads, torque rod
- Measuring the position of the tie rod in the steering gear
- Exposing the steering shaft joint
- Removing front suspension components (both sides)
- Preparations when removing gearbox
- Preparations for lowering the sub-frame
- Removing the right-hand drive shaft
- Removing the left-hand drive shaft
- Lowering the sub-frame
- Removing bevel gear
- Removing the rear engine mounting
- Removing the screws from the torque converter
- Removing the oil pipe from the gearbox
- Lowering the engine and the gearbox
- Installing the fixture on the mobile jack and gearbox
- Removing all the screws for the gearbox and engine
- Removing the gearbox
- Gear-shift position sensor, checking/adjusting
- Notes
- Gear-shift position sensor, checking/adjusting (AW55-50 1999)
- Notes
- Removing engine compartment components
- Remove the gearbox cable from the bracket and the lever. Move the cable to one side
- Checking the setting
- Adjusting the gear-shift position sensor
- Installing the cable duct
- Installing the gear selector cable
- Installing engine compartment components
- Checking the diagnostic trouble codes (DTCs)
- Gear-shift position sensor, checking/adjusting (AW50-42 1999-)
- Gearbox, removing