Phone module (PHM), replacing

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.

The graphics in this service information are used for different model years and/or models. Some variation may occur. However, the essential information in the graphics is always correct.

Removing the phone module (PHM)

Fig 1: Identifying Phone Module, Radio And Casing

Courtesy of VOLVO CARS OF NORTH AMERICA.

Deactivate the phone module (PHM) by removing the reserve battery. See Reserve battery Volvo On Call, replacing .

NOTE: Only car phone module with Volvo On Call has a spare battery.

Remove the radio and carphone. See Radio cassette player, replacing (For -2004) and Audio unit, replacing (For 2005-)

Press in the catches at the top and bottom edges of the car phone.

Disconnect the connectors. Remove the car phone (3).

Installing the phone module (PHM)

Fig 2: Identifying Phone Module, Radio And Casing

Courtesy of VOLVO CARS OF NORTH AMERICA.

Install:

the connectors and the car phone (3)
the radio/telephone. See Radio cassette player, replacing (For -2004) and Audio unit, replacing (For 2005-).

CAUTION: Ensure that the keypad snaps into the radio and frame.

NOTE: After replacing the phone module (PHM), new software must be ordered and the unit programmed.

Without Volvo On Call:

Order the software. See 9438270

With Volvo On Call:

Order the software. See 8633684

Activating Volvo On Call when replacing the phone module (PHM)

After the software is downloaded to the car, "" will appear in the display
Drive the car out. In order for activation to function, the vehicle must be outdoors in an open area.
NOTE: Activation should now be completed within 20 minutes
When the system has determined the position "Confirm by pressing ON CALL" will be displayed
Press the ON CALL button for at least two seconds to make an initial call to the Volvo On Call center. Volvo On Call customer service confirms the position of the car and the name of the dealership
The Volvo On Call system remains deactivated if the connection does not succeed within 20 minutes. The software must be downloaded again and a new attempt to activate the system, with the vehicle outdoors, must be made
When the car is collected ensure that the customer presses ON CALL for at least two seconds to dial up the Volvo On Call Centre for the second time. The Volvo On Call customer services confirms to the customer that the subscription is active and asks for a personal password (at least six characters)
Volvo On Call is now ready for use.