Installing the central electronic module (CEM)
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION:
The pins are fragile. Check that the connectors go straight down into the control module.
Install:
- the control module on the bracket. Press the control module forward so that the catches enter the bracket
- the connectors
- the soundproofing panel on the driver's side
- the 2 screws on top of the control module
- the 2 connectors on top of the control module.
NOTE:
Make sure that the rubber seal is correctly positioned in the groove.
Install:
- the cover
- the wiper arm mechanism. See Wiper mechanism and wiper motor, windshield, replacing
- the battery negative cable. See Battery, disconnecting .