Removing the climate control module (CCM)

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: Detaching Panel At Gear Selector Lever

GLL108231

Courtesy of VOLVO CARS OF NORTH AMERICA.

Detach the panel at the gear selector lever as shown in the illustration.

Twist the panel so that it is as far from the center console as possible.

Fig 2: Identifying Bracket Lower Screws & Infotainment Control Module (ICM)

GLL108218

Courtesy of VOLVO CARS OF NORTH AMERICA.

Remove the lower screws from the bracket.

Angle out the entire infotainment control module (ICM) and the dashboard environment panel as shown in the illustration.

Fig 3: Identifying Infotainment Module Connectors And Screws

GLL108227

Courtesy of VOLVO CARS OF NORTH AMERICA.

Disconnect the connectors.

Turn the infotainment module with the dashboard environment panel.

Remove the four screws as shown in the illustration.

Fig 4: Identifying Infotainment Control Module Removal

GLL108229

Courtesy of VOLVO CARS OF NORTH AMERICA.

Press the four clips and remove the infotainment control module by pulling it straight out as shown in the illustration.

Fig 5: Identifying Dashboard Environment Panel Removal

GLL108233

Courtesy of VOLVO CARS OF NORTH AMERICA.

Slacken off the two screws at the lower edge of the dashboard environment panel.

Pull the dashboard environment panel straight out from the bracket.