LEMON Manuals: Even more car manuals for everyone
Home >> Volvo >> 2002 >> S60 Base, 2.4 61, Standard >> Repair and Diagnosis >> Drivelines & Axles >> Differentials & Drive Axles >> Rear Axle, Drive Shafts - Removal, Replacement And Installation >> Drive Shaft, CV Joint (B5204T5, Aw55-50/51SN; 2004-2007) >> Drive shaft left, replacing >> Remove the drive shaft from the transmission

Remove the drive shaft from the transmission

Fig 1: Identifying Left Drive Shaft From Gearbox & Jimmy Bar
GLL109814

Use jimmy tool 9995462 when removing the drive shaft.

NOTE:

Pull the constant velocity joint  , not the drive shaft joints, when removing the drive shaft. There is no axial pinion.

NOTE:

Take care not to damage the drive shaft when removing it from the transmission.

Fig 2: Identifying Rubber Seal & Constant Velocity Joint
GLL106610
CAUTION:

Later models have a rubber seal on the constant velocity joint. Do not damage the seal. It will be needed for installation.

scientia non olet · About LEMON Manuals