LEMON Manuals: Even more car manuals for everyone
Home >> Volvo >> 1981 >> 245 GLT, Automatic Trans >> Repair and Diagnosis (Single Page) >> Engine Mechanical >> Mechanical >> VOLVO Engines - B21F & B21FT 4-Cylinder >> Engine Cooling >> Water Pump >> Removal & Installation

Removal & Installation

  1. Remove expansion tank cap, open engine block drain cock, and disconnect lower radiator hose at radiator. Remove fan shroud and fan. Loosen alternator and air pump and remove drive belts.
  2. Remove water pump pulley, timing gear cover, and lower radiator hose. Remove retaining bolt and slide coolant pipe rearward. Remove pump.
  3. Clean all surfaces. Place new sealing ring on coolant pipe. Install new gasket when mounting pump. Install other components previously removed. Fill with coolant.
scientia non olet · About LEMON Manuals