LEMON Manuals: Even more car manuals for everyone
Home >> Volkswagen >> 2018 >> Beetle S, 2D Hatchback >> Repair and Diagnosis >> External Pages >> Different car >> Section 241 (Cooling System [CPLA,CPPA,CPKA,CPRA]) >> 19 Cooling System >> Coolant Pump/Thermostat >> Coolant Pump Toothed Belt, Removing And Installing >> Removing

Coolant Pump Toothed Belt, Removing And Installing: Removing

WARNING: This page is about a different car, the 2017 Volkswagen Beetle. However, it is still accessible from the selected car via links, so may be relevant.

-- Drain the coolant. Refer to COOLANT, DRAINING AND FILLING .

-- Remove right front wheel housing liner. Refer to FRONT WHEEL HOUSING LINER, REMOVING AND INSTALLING .

-- Remove the air filter housing. Refer to AIR FILTER HOUSING, REMOVING AND INSTALLING .

-- Loosen the hose clamps -3 and 5-.

Fig 1: Identifying Senors And Clamps
GWWM15-10020Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Disconnect the connector from the Charge Air Pressure Sensor -G31- -arrow-.

-- Remove the bolts -1 and 4- and then remove the air duct pipe downward.

-- Lift the clamp -2-, remove the coolant supports and set them aside.

Fig 2: Identifying Coolant Hose Connectors
GWWA19-11620Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Remove the bolts -arrows- and remove the toothed belt guard -1-.

Fig 3: Identifying Toothed Belt Guard
GWWM19-10042Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Remove the bolts -arrows-.

Fig 4: Identifying Air Guide Pipe
GWWM13-10028Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Disconnect the air duct pipe by lifting the clamps -2- and opening the hose clamp -3-.

-- Counterhold the vibration damper with the :T10355  .

Fig 5: Identifying TDC
GWWN13-10591Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.
NOTE:

The drive gear bolt has a left thread.

-- Counterhold the vibration damper and remove the bolt from the coolant pump the drive wheel -1- by loosening three turns. Use :VAG1410  and :T10360  .

Fig 6: Removing Toothed Belt
GWWN19-10827Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Remove the toothed belt -2-.