LEMON Manuals: Even more car manuals for everyone
Home >> Volkswagen >> 2017 >> Golf S, Eng CD CXBA, Standard Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 9 (Transmission System (Controls & Housing - Service Information - 6-Speed Dual Clutch - 0D9)) >> 34 Controls, Housing >> Front Axle Differential Lock >> Front Axle Differential Lock, Installing

Front Axle Differential Lock, Installing

WARNING: This page is about a different car, the 2017 Volkswagen GTI, 2016 Volkswagen GTI, 2015 Volkswagen Golf, and 2015 Volkswagen GTI. However, it is still accessible from the selected car via links, so may be relevant.

Install in the reverse order of removal while noting the following: 

-- Push the engine/transmission toward the front (a second technician is needed).

-- Slide the front axle differential lock completely onto the transmission. While doing this, join the flange shaft/front axle differential lock centrally with the differential. If necessary, turn on the flange shaft.

-- With the correct tooth position and central guiding, the front axle differential lock slides all the way up against the transmission.

-- Install any cable ties that were loosened or cut off during removal at their same location.

NOTE:

Do not pull the front axle differential lock with the bolts against the transmission, otherwise the front axle differential lock will tilt and the mounting eyes could break.

-- Screw in the lower bolts -arrows- for the front axle differential lock and tighten them. Tightening specification: -item 5-  OVERVIEW - FRONT AXLE DIFFERENTIAL LOCK List Item:Bolt.

GWWN34-12017Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Screw in the upper bolts -arrows- for the front axle differential lock and tighten them. Tightening specification: -item 5-  OVERVIEW - FRONT AXLE DIFFERENTIAL LOCK List Item:Bolt.

GWWN34-12018Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Tighten the flange shaft with a countersunk bolt. Tightening specification: -item 2-  OVERVIEW - FRONT AXLE DIFFERENTIAL LOCK List Item:Bolt.

GWWA34-0615Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Install the new bolts -1- for the pendulum support on the transmission. Refer to SUBFRAME MOUNT [For engine(s) CNSB, CNSA, CXBB, CXBA, CXCB, CXCA] .

GWWN40-10690Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Install the connector -arrow- on the Differential Locks Control Module -J647-.

GWWN34-12013Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Install the right drive axle. Refer to DRIVE AXLE .

GWWA34-10415Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- If equipped, install the drive axle heat shield -arrows-. Refer to DRIVE AXLE .

-- Fill the front axle differential lock. Refer to FRONT AXLE DIFFERENTIAL LOCK FLUID, DRAINING AND FILLING .

-- Assemble the exhaust system. Refer to EXHAUST PIPES/MUFFLERS [For engine(s) CRUA] or EXHAUST PIPES/MUFFLERS [For engine(s) CNSB, CNSA, CXBB, CXBA, CXCB, CXCA] .

-- Install the noise insulation. Refer to NOISE INSULATION .

scientia non olet · About LEMON Manuals