LEMON Manuals: Even more car manuals for everyone
Home >> Volkswagen >> 2009 >> GLI 2.0 J, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 205 (2.0L - Diesel Fuel Injection - Engine Code(S): CBEA & CJAA (Sedan) (A5 Platform)) >> 23 Diesel Fuel Injection >> Removal And Installation >> Engine Control Module -J623- >> Overview

Engine Control Module -J623-: Overview

WARNING: This page is about a different car, the 2010 Volkswagen Jetta and 2009 Volkswagen Jetta. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:

If the Engine Control Module (ECM) is to be replaced, connect the vehicle diagnostic tester and perform "Guided Functions, Replacing Engine Control Module".

Conditions 

Removing 

-- Remove the E-box cover inside the engine compartment -arrows-.

Fig 1: Identifying Engine Control Module (E-Box) Cover
GWWM24-10006Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

ECM with Anti-Theft Protection

Fig 2: Identifying Connectors, Bolts, Bracket And Locking Mechanism
GWWM24-10007Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Remove the shear bolts -2-.

-- Remove the locking mechanism bracket -5-.

-- Disconnect the connectors -1 and 3- from the ECM.

-- Remove the shear bolts -6- and the lock mechanism bracket -4-.

ECM without Anti-Theft Protection

Fig 3: Identifying ECM, Screwdriver And Side Guides
GWWM24-10008Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Disconnect the connectors -1 and 3- from the ECM.

Continuation for all Vehicles

-- Push the tabs on the side guides -3- carefully toward the outside with a screwdriver -2-.

-- Remove the ECM -1- from the guides -3-.

Installing 

-- Install the ECM -1- into the guides -3- until it locks.

Fig 4: Identifying ECM, Screwdriver And Side Guides
GWWM24-10008Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

ECM with Anti-Theft Protection

Fig 5: Identifying Connectors, Bolts, Bracket And Locking Mechanism
GWWM24-10007Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- At Tach the locking mechanism bracket -4- to the ECM with the shear bolts -6-.

-- Install the shear bolts until the bolt heads break off.

-- Connect the connectors -1 and 3- to the ECM.

-- Install the locking mechanism bracket -5- with the shear bolts -6-.

-- Install the shear bolts until the bolt heads break off.

ECM without Anti-Theft Protection

-- Connect the connectors -1 and 3- to the ECM.

Continuation for all Vehicles

Fig 6: Identifying Engine Control Module (E-Box) Cover
GWWM24-10006Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Install the E-box cover -arrows-.