General Repair Information: Transmission
WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2010 Volkswagen Jetta, 2009 Volkswagen Jetta, 2009 Volkswagen GLI, 2008 Volkswagen Jetta, and 2008 Volkswagen GLI. However, it is still accessible from the selected car via links, so may be relevant.
Always make sure that no dirt enters an >>open<< transmission. Dirt entering an >>open<< transmission can cause a malfunction especially with a >>open<< DSG transmission mechatronic -J743- and/or oil pump.
- Do not run the engine and do not tow the vehicle if the transmission cover is removed or if there is no transmission fluid inside the transmission.
- Always clean the connection points and the area around them first, then loosen them.
- When installing the transmission, make sure the alignment sleeves are correctly seated between the engine and transmission.
- Place removed parts on a clean surface and cover them so that they do not get dirty. Use foil or paper. Use a lint free cloth.
- Only install clean components. Install replacement parts immediately after removing them from their packaging.
- Carefully cover or plug unpacked components if repairs cannot be performed immediately.