LEMON Manuals: Even more car manuals for everyone
Home >> Volkswagen >> 2005 >> Jetta TDI, Automatic >> Repair and Diagnosis >> Engine Performance >> Testing & Diagnosis >> 1.9L - Fuel Supply System - BKC, BLS, BRM & BXE (A5 Platform) >> 20 Fuel Supply System >> General Information >> Fuel Tank Draining >> Tank Less Than 3/4 Full

Tank Less Than 3/4 Full

-- Turn the ignition and all electrical consumers off and remove the ignition key.

-- Remove seat bench Removal and Installation .

-- Unclip cover -1- from fuel delivery unit. Arrow -2- points in direction of travel.

Fig 1: Identifying Fuel Delivery Unit Cover
GWWM20-0233Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.
WARNING:
  • The fuel or fuel lines in fuel system can become very hot (danger of scalding)!
  • In addition, the fuel system is under pressure! Before opening the system, place rags around the connection area and release pressure by carefully loosening the connection!
  • Wear protective goggles and protective gloves when working on the fuel system!

-- Disconnect the connector -1-, the supply line -2- and the return line -3- from the fuel delivery unit.

Fig 2: Identifying 4-Pin Connector, Black Supply Line And Blue Return Line From Fuel Delivery Unit
GWWM20-0232Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.
NOTE:

Press in securing ring to disengage the lines.

On vehicles equipped with an auxiliary heater, the metering pump -V54- electrical connector must also be disconnected and the fuel pipe must be removed.

-- Open locking ring using wrench T10202.

Fig 3: Identifying Wrench T10202 In Locking Ring
GWWN20-0638Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Pull out fuel delivery unit slightly.

-- Insert the fuel extracting device VAS 5190 suction hose as far as possible into the fuel tank and extract the fuel.

If the fuel tank needs only to be drained, install fuel delivery unit again.