ATF, Topping Off

WARNING: This page does not describe the selected car, but rather 11 other vehicles, including the 2006 Volkswagen Golf, 2006 Volkswagen GTI, 2005 Volkswagen Jetta, 2005 Volkswagen Golf, and 2005 Volkswagen GTI. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: Identifying Special Tool - VAS 6262/2

Courtesy of VOLKSWAGEN UNITED STATES, INC.

With engine running , install adapter for filling oil VAS 6262/2 hand tight.

Fig 2: Identifying Special Tools - VAS 6262, VAS 6262/2, VAS 5051

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Add 1 l of ATF.
Remove adapter for oil filling VAS 6262 at quick-release connection and check:

If ATF now flows out of hole in adapter:

ATF does not need topping off.

Drain ATF until it drips.
Install new seal to plug and tighten to 15 Nm. This completes ATF check.

If no ATF drips out:

Add another liter, refer to ATF, topping off .

CAUTION: An ATF level which is too low or too high will impair the function of the transmission. But if the transmission was 2 liters low, it must be carefully inspected. There is probably a major leak.