LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2025 >> RAV4 Plug-In Hybrid XSE >> Repair and Diagnosis >> Maintenance >> Procedures >> Maintenance - Service Information (PHEV) >> A25A-FXS Auxiliary Battery >> Removal [12/2021 - 10/2022] >> Procedure

Removal [12/2021 - 10/2022]: Procedure

  1. PRECAUTION 
    NOTE:
    • After turning the ignition switch is turned off, there may be a waiting time before disconnecting the negative (-) auxiliary battery terminal.

      Refer to BEFORE DISCONNECTING BATTERY [06/2020 - 10/2022]

    • When replacing the auxiliary battery, use a new battery of the same dimensions with a capacity of 55 Ah or more at a 20-hour rate.
    • After replacing the auxiliary battery, install the ventilation hole plug supplied with the new auxiliary battery or the ventilation hole plug from the old auxiliary battery to the ventilation hole on the side to which the battery hose is not connected.
  2. REMOVE DECK BOARD ASSEMBLY 
    1. Remove the deck board assembly.
      GTY995998Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  3. REMOVE BATTERY HOLE COVER 
    GTY996627Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    1. Detach the 13 claws and remove the battery hole cover.
  4. DISCONNECT CABLE FROM NEGATIVE AUXILIARY BATTERY TERMINAL 
    1. Loosen the nut, and disconnect the cable from the negative (-) auxiliary battery terminal.
      GTY996624Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Set the negative (-) auxiliary battery terminal to the deck trim side panel assembly RH.
      GTY996631Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  5. REMOVE AUXILIARY BATTERY 
    1. Open the connector cover.
      GTY996628Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Loosen the nut and disconnect the cable from the positive (+) auxiliary battery terminal.
      GTY996632Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    3. Disconnect the battery hose from the auxiliary battery.
      GTY996001Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    4. Remove the bolt, nut and battery clamp sub-assembly as shown in the illustration.
      GTY995978Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    5. Remove the auxiliary battery.
scientia non olet · About LEMON Manuals