DTC P3000-4B: Hybrid/EV Battery Control System Over Temperature [03/2023 - ]: Procedure

HINT: 

Refer to INSPECTION [03/2023 - ]

Result

Result: 

NEXT 

See step  2

Pre-procedure1

1. None

   Procedure1

2. Check for DTCs.

   Powertrain > HV Battery > Trouble Codes 

   Powertrain > Hybrid Control > Trouble Codes 

   Result

   Result	Proceed to
   "P3000-4B" only is output, or DTCs except the ones in the table below are also output.	A
   DTCs of hybrid battery system in the table below are output.	B
   DTCs of hybrid control system in the table below are output.	C

   System	Relevant DTC
   Hybrid battery system	P060A-47	Hybrid/EV Battery Energy Control Module Monitoring Processor Watchdog / Safety MCU Failure
   	P060B-49	Hybrid/EV Battery Energy Control Module A/D Processing Internal Electronic Failure
   	P0606-87	Hybrid/EV Battery Energy Control Module Processor to Monitoring Processor Missing Message
   	P0A9B-11	Hybrid/EV Battery Temperature Sensor "A" Circuit Short to Ground
   	P0A9B-15	Hybrid/EV Battery Temperature Sensor "A" Circuit Short to Auxiliary Battery or Open
   	P0A9B-1C	Hybrid/EV Battery Temperature Sensor "A" Voltage Out of Range
   	P0A9B-2A	Hybrid/EV Battery Temperature Sensor "A" Signal Stuck In Range
   	P0AAC-11	Hybrid/EV Battery Air Temperature Sensor "A" Circuit Short to Ground
   	P0AAC-15	Hybrid/EV Battery Air Temperature Sensor "A" Circuit Short to Auxiliary Battery or Open
   	P0AB1-11	Hybrid/EV Battery Air Temperature Sensor "B" Circuit Short to Ground
   	P0AB1-15	Hybrid/EV Battery Air Temperature Sensor "B" Circuit Short to Auxiliary Battery or Open
   	P0AC5-11	Hybrid/EV Battery Temperature Sensor "B" Circuit Short to Ground
   	P0AC5-15	Hybrid/EV Battery Temperature Sensor "B" Circuit Short to Auxiliary Battery or Open
   	P0AC5-1C	Hybrid/EV Battery Temperature Sensor "B" Voltage Out of Range
   	P0AC5-2A	Hybrid/EV Battery Temperature Sensor "B" Signal Stuck In Range
   	P0ACA-11	Hybrid/EV Battery Temperature Sensor "C" Circuit Short to Ground
   	P0ACA-15	Hybrid/EV Battery Temperature Sensor "C" Circuit Short to Auxiliary Battery or Open
   	P0ACA-1C	Hybrid/EV Battery Temperature Sensor "C" Voltage Out of Range
   	P0ACA-2A	Hybrid/EV Battery Temperature Sensor "C" Signal Stuck In Range
   	P0AE8-11	Hybrid/EV Battery Temperature Sensor "D" Circuit Short to Ground
   	P0AE8-15	Hybrid/EV Battery Temperature Sensor "D" Circuit Short to Auxiliary Battery or Open
   	P0AE8-1C	Hybrid/EV Battery Temperature Sensor "D" Voltage Out of Range
   	P0AE8-2A	Hybrid/EV Battery Temperature Sensor "D" Signal Stuck In Range
   	P0BC2-11	Hybrid/EV Battery Temperature Sensor "E" Circuit Short to Ground
   	P0BC2-15	Hybrid/EV Battery Temperature Sensor "E" Circuit Short to Auxiliary Battery or Open
   	P0BC2-1C	Hybrid/EV Battery Temperature Sensor "E" Voltage Out of Range
   	P0BC2-2A	Hybrid/EV Battery Temperature Sensor "E" Signal Stuck In Range
   	P0C33-11	Hybrid/EV Battery Temperature Sensor "F" Circuit Short to Ground
   	P0C33-15	Hybrid/EV Battery Temperature Sensor "F" Circuit Short to Auxiliary Battery or Open
   	P0C33-1C	Hybrid/EV Battery Temperature Sensor "F" Voltage Out of Range
   	P0C33-2A	Hybrid/EV Battery Temperature Sensor "F" Signal Stuck In Range
   	P0C7C-11	Hybrid/EV Battery Temperature Sensor "G" Circuit Short to Ground
   	P0C7C-15	Hybrid/EV Battery Temperature Sensor "G" Circuit Short to Auxiliary Battery or Open
   	P0C7C-1C	Hybrid/EV Battery Temperature Sensor "G" Voltage Out of Range
   	P0C7C-2A	Hybrid/EV Battery Temperature Sensor "G" Signal Stuck In Range
   	P0C81-11	Hybrid/EV Battery Temperature Sensor "H" Circuit Short to Ground
   	P0C81-15	Hybrid/EV Battery Temperature Sensor "H" Circuit Short to Auxiliary Battery or Open
   	P0C81-1C	Hybrid/EV Battery Temperature Sensor "H" Voltage Out of Range
   	P0C81-2A	Hybrid/EV Battery Temperature Sensor "H" Signal Stuck In Range
   	P0C88-11	Hybrid/EV Battery Temperature Sensor "I" Circuit Short to Ground
   	P0C88-15	Hybrid/EV Battery Temperature Sensor "I" Circuit Short to Auxiliary Battery or Open
   	P0C88-1C	Hybrid/EV Battery Temperature Sensor "I" Voltage Out of Range
   	P0C88-2A	Hybrid/EV Battery Temperature Sensor "I" Signal Stuck In Range
   Hybrid battery system	P0C8D-11	Hybrid/EV Battery Temperature Sensor "J" Circuit Short to Ground
   	P0C8D-15	Hybrid/EV Battery Temperature Sensor "J" Circuit Short to Auxiliary Battery or Open
   	P0C8D-1C	Hybrid/EV Battery Temperature Sensor "J" Voltage Out of Range
   	P0C8D-2A	Hybrid/EV Battery Temperature Sensor "J" Signal Stuck In Range
   	P0C92-11	Hybrid/EV Battery Temperature Sensor "K" Circuit Short to Ground
   	P0C92-15	Hybrid/EV Battery Temperature Sensor "K" Circuit Short to Auxiliary Battery or Open
   	P0C92-1C	Hybrid/EV Battery Temperature Sensor "K" Voltage Out of Range
   	P0C92-2A	Hybrid/EV Battery Temperature Sensor "K" Signal Stuck In Range
   	P0C97-11	Hybrid/EV Battery Temperature Sensor "L" Circuit Short to Ground
   	P0C97-15	Hybrid/EV Battery Temperature Sensor "L" Circuit Short to Auxiliary Battery or Open
   	P0C97-1C	Hybrid/EV Battery Temperature Sensor "L" Voltage Out of Range
   	P0C97-2A	Hybrid/EV Battery Temperature Sensor "L" Signal Stuck In Range
   	P0CA8-11	Hybrid/EV Battery Temperature Sensor "M" Circuit Short to Ground
   	P0CA8-15	Hybrid/EV Battery Temperature Sensor "M" Circuit Short to Auxiliary Battery or Open
   	P0CA8-1C	Hybrid/EV Battery Temperature Sensor "M" Voltage Out of Range
   	P0CA8-2A	Hybrid/EV Battery Temperature Sensor "M" Signal Stuck In Range
   	P0CAD-11	Hybrid/EV Battery Temperature Sensor "N" Circuit Short to Ground
   	P0CAD-15	Hybrid/EV Battery Temperature Sensor "N" Circuit Short to Auxiliary Battery or Open
   	P0CAD-1C	Hybrid/EV Battery Temperature Sensor "N" Voltage Out of Range
   	P0CAD-2A	Hybrid/EV Battery Temperature Sensor "N" Signal Stuck In Range
   	P0CB2-11	Hybrid/EV Battery Temperature Sensor "O" Circuit Short to Ground
   	P0CB2-15	Hybrid/EV Battery Temperature Sensor "O" Circuit Short to Auxiliary Battery or Open
   	P0CB2-1C	Hybrid/EV Battery Temperature Sensor "O" Voltage Out of Range
   	P0CB2-2A	Hybrid/EV Battery Temperature Sensor "O" Signal Stuck In Range
   	P0CB7-11	Hybrid/EV Battery Temperature Sensor "P" Circuit Short to Ground
   	P0CB7-15	Hybrid/EV Battery Temperature Sensor "P" Circuit Short to Auxiliary Battery or Open
   	P0CB7-1C	Hybrid/EV Battery Temperature Sensor "P" Circuit Voltage Out of Range
   	P0CB7-2A	Hybrid/EV Battery Temperature Sensor "P" Signal Stuck In Range
   	P1B5B-11	Hybrid/EV Battery Temperature Sensor "Q" Circuit Short to Ground
   	P1B5B-15	Hybrid/EV Battery Temperature Sensor "Q" Circuit Short to Auxiliary Battery or Open
   	P1B5B-1C	Hybrid/EV Battery Temperature Sensor "Q" Circuit Voltage Out of Range
   	P1B5B-2A	Hybrid/EV Battery Temperature Sensor "Q" Signal Stuck In Range
   	P1B60-11	Hybrid/EV Battery Temperature Sensor "R" Circuit Short to Ground
   	P1B60-15	Hybrid/EV Battery Temperature Sensor "R" Circuit Short to Auxiliary Battery or Open
   	P1B60-1C	Hybrid/EV Battery Temperature Sensor "R" Circuit Voltage Out of Range
   	P1B60-2A	Hybrid/EV Battery Temperature Sensor "R" Signal Stuck In Range
   	P1B65-11	Hybrid/EV Battery Temperature Sensor "S" Circuit Short to Ground
   	P1B65-15	Hybrid/EV Battery Temperature Sensor "S" Circuit Short to Auxiliary Battery or Open
   	P1B65-1C	Hybrid/EV Battery Temperature Sensor "S" Circuit Voltage Out of Range
   	P1B65-2A	Hybrid/EV Battery Temperature Sensor "S" Signal Stuck In Range
   	P1B6A-11	Hybrid/EV Battery Temperature Sensor "T" Circuit Short to Ground
   	P1B6A-15	Hybrid/EV Battery Temperature Sensor "T" Circuit Short to Auxiliary Battery or Open
   	P1B6A-1C	Hybrid/EV Battery Temperature Sensor "T" Circuit Voltage Out of Range
   	P1B6A-2A	Hybrid/EV Battery Temperature Sensor "T" Signal Stuck In Range
   	P3065-62	Hybrid/EV Battery Temperature Sensor "Group 1" Signal Compare Failure
   	P306A-62	Hybrid/EV Battery Temperature Sensor "Group 2" Signal Compare Failure
   	P306B-62	Hybrid/EV Battery Temperature Sensor "Group 3" Signal Compare Failure
   	P306F-62	Hybrid/EV Battery Temperature Sensor "Group 4" Signal Compare Failure
   Hybrid control system	P0A1F-94	Hybrid/EV Battery Energy Control Module Unexpected Operation

   Post-procedure1

3. Turn the ignition switch off.

Result: 

B 

GO TO DTC CHART (HYBRID BATTERY SYSTEM). Refer To  DIAGNOSTIC TROUBLE CODE CHART [03/2023 - ] 

Result: 

C 

GO TO DTC CHART (HYBRID CONTROL SYSTEM) 

Refer to DIAGNOSTIC TROUBLE CODE CHART [03/2023 - 01/2025] , or refer to DIAGNOSTIC TROUBLE CODE CHART [01/2025 - ]

Result: 

A 

See step  3

HINT: 

Refer to REMOVAL [03/2023 - ]

Result

Result: 

NEXT 

REPLACE HV SUPPLY BATTERY ASSEMBLY 

Refer to REMOVAL [03/2023 - ]