Caution / Notice / Hint

The necessary procedures (adjustment, calibration, initialization or registration) that must be performed after parts are removed, installed or replaced during the roof headlining assembly removal/installation are shown below.

HINT:

When the cable is disconnected/reconnected to the auxiliary battery terminal, systems temporarily stop operating. However, each system has a function that completes learning the first time the system is used.

Learning completes when vehicle is driven

Effect/Inoperative Function When Necessary Procedures are not Performed	Necessary Procedures	Link
Front camera system	Drive the vehicle straight ahead at 35 km/h (22 mph) or more for 5 seconds or more.	Refer to INITIALIZATION [02/2024 - ]

Learning completes when vehicle is operated normally

Effect/Inoperative Function When Necessary Procedures are not Performed	Necessary Procedures	Link
Air conditioning system	After the ignition switch is turned to ON, the servo motor standard position is recognized.	-
Power back door system	Fully close the back door by hand. HINT: Initialization is not necessary if the above procedures are performed while the back door is closed.	Refer to INITIALIZATION [02/2024 - ]

COMPONENTS (REMOVAL)

Fig 1: Roof Headlining Removal Components (1 Of 7)

Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

Procedure		Part Name Code
1	PRECAUTION	-	See step 1	-	-
2	DRAIN WINDSHIELD WASHER FLUID	-	-	See step 2	-
3	TONNEAU COVER ASSEMBLY	64910N	-	-	-
4	FRONT SEAT ASSEMBLY LH	64910M	-	-	-
5	FRONT SEAT ASSEMBLY RH	-	-	-	-
6	REAR NO. 1 SEAT ASSEMBLY LH	-	-	-	-
7	REAR NO. 1 SEAT ASSEMBLY RH	-	-	-	-
8	REAR NO. 2 SEAT ASSEMBLY	-	-	-	-

w/ Rear No. 2 Seat

w/ Tonneau Cover

Fig 2: Roof Headlining Removal Components (2 Of 7)

Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

Procedure		Part Name Code
9	ROPE HOOK ASSEMBLY	-	-	-	-

w/o Rear No. 2 Seat

Fig 3: Roof Headlining Removal Components (3 Of 7)

Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

Procedure		Part Name Code
10	DECK BOARD ASSEMBLY	58410B	-	-	-
11	DECK BOARD ASSEMBLY	58410B	-	-	-
12	REAR DECK FLOOR BOX	64993	See step 12	-	-
13	REAR FLOOR BOARD REAR LH	58418H	-	-	-
14	REAR FLOOR BOARD REAR RH	58417B	-	-	-
15	REAR FLOOR MAT REAR SUPPORT PLATE	58574A	-	-	-
16	DECK SIDE TRIM BOX RH	64741B	-	-	-
17	REAR DECK FLOOR BOX	64993	-	-	-
18	REAR NO. 1 FLOOR BOARD ASSEMBLY	58470E	-	-	-

w/o Rear No. 2 Seat

Fig 4: Roof Headlining Removal Components (4 Of 7)

Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

Procedure		Part Name Code
19	FRONT DOOR SCUFF PLATE LH	67914B	-	-	-
20	FRONT DOOR SCUFF PLATE RH	67913B	-	-	-
21	COWL SIDE TRIM BOARD LH	62112	-	-	-
22	COWL SIDE TRIM BOARD RH	62111C	-	-	-
23	ASSIST GRIP PLUG	-	-	-	-
24	PILLAR ASSIST GRIP ASSEMBLY	74680	-	-	-
25	FRONT PILLAR GARNISH ASSEMBLY LH	62212B	See step 25	-	-
26	FRONT PILLAR GARNISH ASSEMBLY RH	62211U	See step 25	-	-
27	FRONT DOOR OPENING TRIM WEATHERSTRIP LH	62312B	-	-	-
28	FRONT DOOR OPENING TRIM WEATHERSTRIP RH	62311B	-	-	-
29	REAR DOOR SCUFF PLATE LH	67918E	-	-	-
30	REAR DOOR SCUFF PLATE RH	67917C	-	-	-
31	REAR DOOR OPENING TRIM WEATHERSTRIP LH	62332C	-	-	-
32	REAR DOOR OPENING TRIM WEATHERSTRIP RH	62331C	-	-	-
33	ASSIST GRIP PLUG	74617W	-	-	-
34	ASSIST GRIP PLUG	74617V	-	-	-
35	PILLAR ASSIST GRIP ASSEMBLY LH	74680C	-	-	-
36	PILLAR ASSIST GRIP ASSEMBLY RH	74680B	-	-	-
37	OUTER LAP BELT ANCHOR COVER	73233	-	-	-
38	FRONT SEAT OUTER BELT ASSEMBLY LH (LAP BELT ANCHOR)	73220	-	-	-
39	FRONT SEAT OUTER BELT ASSEMBLY RH (LAP BELT ANCHOR)	73210	-	-	-
40	CENTER PILLAR LOWER GARNISH LH	62414A	-	-	-
41	CENTER PILLAR LOWER GARNISH RH	62413A	-	-	-
42	CENTER PILLAR GARNISH LH	62412	-	-	-
43	CENTER PILLAR GARNISH RH	62411	-	-	-

•

Non-reusable part

Fig 5: Roof Headlining Removal Components (5 Of 7)

Procedure		Part Name Code
44	OUTER LAP BELT ANCHOR COVER	73233D	-	-	-
45	REAR NO. 1 SEAT OUTER BELT ASSEMBLY LH (LAP BELT ANCHOR)	73370C	-	-	-
46	REAR NO. 1 SEAT OUTER BELT ASSEMBLY RH (LAP BELT ANCHOR)	73360C	-	-	-
47	REAR NO. 2 SEAT OUTER BELT ASSEMBLY LH (LAP BELT ANCHOR)	73570	-	-	-
48	REAR NO. 2 SEAT OUTER BELT ASSEMBLY RH (LAP BELT ANCHOR)	73560	-	-	-
49	NO. 1 TONNEAU COVER HOLDER CAP	64937A	-	-	-
50	NO. 1 LUGGAGE COMPARTMENT TRIM HOOK	64725D	-	-	-
51	NO. 2 CUP HOLDER	66992	See step 51	-	-
52	NO. 1 CUP HOLDER	66991B	See step 51	-	-
53	BATTERY SERVICE HOLE COVER ASSEMBLY LH	58440J	-	-	-
54	BATTERY SERVICE HOLE COVER ASSEMBLY RH	58440H	-	-	-
55	DECK TRIM SIDE PANEL ASSEMBLY LH	64740C	-	-	-
56	DECK TRIM SIDE PANEL ASSEMBLY RH	64730B	-	-	-
57	FRONT QUARTER TRIM PANEL ASSEMBLY LH	62520P	-	-	-
58	FRONT QUARTER TRIM PANEL ASSEMBLY RH	62510P	-	-	-
59	REAR QUARTER TRIM PANEL ASSEMBLY LH	62640P	-	-	-
60	REAR QUARTER TRIM PANEL ASSEMBLY RH	62630P	-	-	-
61	NO. 1 ROOF SIDE RAIL GARNISH LH	62432B	-	-	-
62	NO. 1 ROOF SIDE RAIL GARNISH RH	62431B	-	-	-

*A	w/ Rear No. 2 Seat	-	-
•	Non-reusable part	-	-

Fig 6: Roof Headlining Removal Components (6 Of 7)

Procedure		Part Name Code
63	ASSIST GRIP SUB-ASSEMBLY	74610A	See step 63	-	-
64	REAR ASSIST GRIP ASSEMBLY LH	74630E	See step 63	-	-
65	REAR ASSIST GRIP ASSEMBLY RH	74620C	See step 63	-	-
66	ASSIST GRIP	74611B	-	-	-
67	MAP LIGHT ASSEMBLY	-	See step 67	-	-
68	VANITY LIGHT ASSEMBLY	81340	See step 68	-	-
69	NO. 1 ROOM LIGHT ASSEMBLY	81240	See step 69	-	-
70	NO. 2 FORWARD RECOGNITION COVER	86466E	See step 70	-	-
71	NO. 1 FORWARD RECOGNITION COVER	86466D	See step 71	-	-
72	VISOR BRACKET COVER	74325	-	-	-
73	VISOR ASSEMBLY LH	74320	-	-	-
74	VISOR ASSEMBLY RH	74310	-	-	-
75	VISOR HOLDER	74348	-	-	-

ASSIST GRIP COVER

Fig 7: Roof Headlining Removal Components (7 Of 7)

Procedure		Part Name Code
76	ROOF HEADLINING ASSEMBLY	-	See step 76	-	-

for Moon Roof

for Normal Roof