LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2021 >> RAV4 Prime SE >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> Exterior Panels / Trim - Service Information (2 Of 3) (PHEV) >> Rear Door Outside Moulding >> Removal [06/2020 - ] >> Procedure

Removal [06/2020 - ]: Procedure

  1. REMOVE REAR DOOR NO. 5 WEATHERSTRIP LH 

    Refer to PROCEDURE - Step 41 [06/2020 - 12/2021] , or refer to PROCEDURE - Step 41 [12/2021 - 10/2022] , or refer to PROCEDURE - Step 41 [10/2022 - ]

  2. REMOVE REAR DOOR LOWER OUTSIDE MOULDING SUB-ASSEMBLY LH 
    1. Remove the clip.
      GTY888678Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Put protective tape around the rear door lower outside moulding sub-assembly LH.
      GTY867184Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Protective Tape
    3. Remove the hole plug.
      GTY888674Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    4. Remove the nut.
      GTY888675Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    5. Detach the clip and remove the rear door lower outside moulding sub-assembly LH as shown in the illustration.
      GTY1006287Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Place Hand Here
      Remove in this Direction
  3. REMOVE OUTSIDE MOULDING SET LH 
    1. Remove the screw and clip.
      GTY925749Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Screw
      Clip
    2. Put protective tape around the outside moulding set LH.
      GTY917125Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Protective Tape
    3. Detach the clip and claw and remove the outside moulding set LH as shown in the illustration.
      GTY1006386Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Place Hand Here
      Remove in this Direction
  4. REMOVE NO. 2 ACCESS PANEL WEATHERSTRIP LH 
    1. Detach the clip and remove the No. 2 access panel weatherstrip LH.
      GTY888660Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  5. REMOVE REAR DOOR PANEL PROTECTOR LH 
    1. Remove the screw and clip.
      GTY856637Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Screw
      Clip
    2. Put protective tape around the rear door panel protector LH.
      GTY861665Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Protective Tape
    3. Detach the claw and guide to remove the rear door panel protector LH as shown in the illustration.
      GTY895357Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction
scientia non olet · About LEMON Manuals