Headlight Beam Level Control Actuator Circuit [11/2020 - 12/2023]: Procedure

1. Perform the Active Test according to the display on the GTS.

   Body Electrical > HL AutoLeveling > Active Test 

   Tester Display	Measurement Item	Control Range	Diagnostic Note
   Drive The Leveling Motor	Headlight leveling motor upward or downward operation	Stop, Down or Up	Perform the Active Test with the hybrid control system started and vehicle stopped

   Body Electrical > HL AutoLeveling > Active Test 

   Tester Display
   Drive The Leveling Motor

   OK

   Headlight leveling motors operate normally.

   Result

   Result	Proceed to
   OK	A
   NG (for LH Side)	B
   NG (for RH Side)	C

Result: 

A 

PROCEED TO NEXT SUSPECTED AREA SHOWN IN PROBLEM SYMPTOMS TABLE. Refer to  PROBLEM SYMPTOMS TABLE [11/2020 - 12/2023] 

Result: 

C 

See step  4

Result: 

B 

See step  2

1. Interchange the headlight unit assembly LH with RH and connect the connectors.

   Refer to DISASSEMBLY [11/2020 - 11/2021] , or refer to DISASSEMBLY [11/2021 - 12/2023]

   Result

   Proceed to
   NEXT

Result: 

NEXT 

See step  3

1. Check that the headlight leveling motor LH operates normally.

   Refer to OPERATION CHECK [11/2020 - 12/2023]

   OK

   Headlight leveling motor LH operates normally.

   Result

   Proceed to
   OK
   NG

Result: 

OK 

REPLACE HEADLIGHT ECU SUB-ASSEMBLY LH. Refer to  REMOVAL [11/2020 - 11/2021]  , or refer to  REMOVAL [11/2021 - 12/2022]  , or refer to  REMOVAL [12/2022 - 12/2023] 

Result: 

NG 

REPLACE HEADLIGHT UNIT ASSEMBLY LH. Refer to  DISASSEMBLY [11/2020 - 11/2021]  , or refer to  DISASSEMBLY [11/2021 - 12/2023] 

1. Interchange the headlight unit assembly RH with LH and connect the connectors.

   Refer to DISASSEMBLY [11/2020 - 11/2021] , or refer to DISASSEMBLY [11/2021 - 12/2023]

   Result

   Proceed to
   NEXT

Result: 

NEXT 

See step  5

1. Check that the headlight leveling motor RH operates normally.

   Refer to OPERATION CHECK [11/2020 - 12/2023]

   OK

   Headlight leveling motor RH operates normally.

   Result

   Proceed to
   OK
   NG

Result: 

OK 

REPLACE HEADLIGHT ECU SUB-ASSEMBLY RH. Refer to  REMOVAL [11/2020 - 11/2021]  , or refer to  REMOVAL [11/2021 - 12/2022]  , or refer to  REMOVAL [12/2022 - 12/2023] 

Result: 

NG 

REPLACE HEADLIGHT UNIT ASSEMBLY RH. Refer to  DISASSEMBLY [11/2020 - 11/2021]  , or refer to  DISASSEMBLY [11/2021 - 12/2023]