LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2021 >> Camry TRD >> Repair and Diagnosis >> Restraints >> Air Bag, SRS >> Supplemental Restraint System - Service Information (1 Of 2) (Except Hybrid) >> Front Passenger Airbag Assembly >> Installation [03/2017 - ] >> Procedure

Installation [03/2017 - ]: Procedure

  1. INSTALL NO. 5 INSTRUMENT PANEL WIRE 
    1. Connect the 2 airbag connectors of the No. 5 instrument panel wire to the instrument panel passenger airbag assembly.
      GTY763856Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *a Airbag Connector
      *b Airbag Connector Locking Button
      Push in this Direction
      NOTE:
      • When connecting any airbag connector, take care not to damage the airbag wire harness.
      • Be sure to only connect the connectors to each corresponding color.
    2. Push in the 2 airbag connector locking buttons to install the 2 airbag connectors to the instrument panel passenger airbag assembly.
  2. INSTALL INSTRUMENT PANEL PASSENGER AIRBAG ASSEMBLY 
    1. Engage the 3 hooks.
      GTY770221Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Push in the instrument panel passenger airbag assembly to engage the 3 hooks.
      GTY748245Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    3. Install the instrument panel passenger airbag assembly with the 2 screws.
      GTY748246Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    4. Engage the clamp.
  3. INSTALL INSTRUMENT PANEL SAFETY PAD SUB-ASSEMBLY 

    Refer to PROCEDURE - Step 1 [03/2017 - 06/2017] , or refer to PROCEDURE - Step 1 [06/2017 - 10/2020] , or refer to PROCEDURE - Step 1 [10/2020 - ]

  4. CONNECT NO. 5 INSTRUMENT PANEL WIRE 
    1. Check that the ignition switch is off.
    2. Check that the cable is disconnected from the negative (-) battery terminal.
      WARNING:

      Wait at least 90 seconds after disconnecting the cable from the negative (-) battery terminal to disable the SRS system.

      GTY684647Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    3. Connect the connector.
      GTY748221Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      NOTE:

      When connecting any airbag connector, take care not to damage the airbag wire harness.

  5. INSTALL NO. 1 INSTRUMENT PANEL REGISTER ASSEMBLY 

    Refer to PROCEDURE - Step 3 [03/2017 - 06/2017] , or refer to PROCEDURE - Step 3 [06/2017 - 10/2020] , or refer to PROCEDURE - Step 3 [10/2020 - ]

scientia non olet · About LEMON Manuals