LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2021 >> Avalon TRD >> Repair and Diagnosis >> Accessories & Equipment >> Interior/Exterior Trim >> EXTERIOR PANELS / TRIM (SERVICE INFORMATION) (2 Of 2) >> Rear Bumper >> Disassembly [04/2018 - 08/2019] >> Procedure

Disassembly [04/2018 - 08/2019]: Procedure

  1. REMOVE REAR CENTER ULTRASONIC SENSOR (w/ Intuitive Parking Assist System) 

    Refer to PROCEDURE - Step 2

    HINT: 

    Use the same procedure for the RH side and LH side.

  2. REMOVE REAR CORNER ULTRASONIC SENSOR (w/ Intuitive Parking Assist System) 

    Refer to PROCEDURE - Step 3

    HINT: 

    Use the same procedure for the RH side and LH side.

  3. REMOVE REAR CENTER ULTRASONIC SENSOR RETAINER (w/ Intuitive Parking Assist System) 

    Refer to PROCEDURE - Step 5

    HINT: 

    Use the same procedure for the RH side and LH side.

  4. REMOVE REAR CORNER ULTRASONIC SENSOR RETAINER (w/ Intuitive Parking Assist System) 

    Refer to PROCEDURE - Step 6

    HINT: 

    Use the same procedure for the RH side and LH side.

  5. REMOVE FOG LIGHT SEAL (w/ Intuitive Parking Assist System) 
    1. Remove the 5 fog light seals.
      GTY867731Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  6. REMOVE NO. 2 LUGGAGE ROOM WIRE (w/ Intuitive Parking Assist System) 
  7. REMOVE REFLEX REFLECTOR ASSEMBLY LH 
    GTY867730Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    1. Remove the screw.
    2. Disengage the 2 guides to remove the reflex reflector assembly LH as shown in the illustration.
      GTY909211Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction (1)
      Remove in this Direction (2)
  8. REMOVE REFLEX REFLECTOR ASSEMBLY RH 

    HINT: 

    Use the same procedure as for the LH side.

  9. REMOVE LOWER REAR BUMPER COVER 
    1. Remove the 2 clips (A).
      GTY921053Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Remove the 4 clips (B).
    3. Disengage the 14 claws and 2 guides to remove the lower rear bumper cover.
      GTY867733Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  10. REMOVE REAR BUMPER SIDE RETAINER LH 
    1. Remove the screw.
      GTY867728Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Disengage the 3 clips as shown in the illustration.
      GTY847366Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction
    3. Disengage the 2 claws as shown in the illustration.
      GTY868419Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction (1)
      Remove in this Direction (2)
    4. Disengage the guide to remove the rear bumper side retainer LH.
  11. REMOVE REAR BUMPER SIDE RETAINER RH 

    HINT: 

    Use the same procedure as for the LH side.

  12. REMOVE SPARE WHEEL COVER ASSEMBLY 

    Refer to PROCEDURE - Step 1

  13. REMOVE BAGGAGE HOLDER NET 

    Refer to PROCEDURE - Step 2

  14. REMOVE NO. 1 LUGGAGE COMPARTMENT TRIM HOOK 

    Refer to PROCEDURE - Step 3

  15. REMOVE REAR FLOOR FINISH PLATE 

    Refer to PROCEDURE - Step 4

  16. REMOVE LUGGAGE COMPARTMENT INNER TRIM PAD 

    Refer to PROCEDURE - Step 5

  17. REMOVE LUGGAGE TRIM SERVICE HOLE COVER (for HV Model) 

    Refer to PROCEDURE - Step 2

  18. REMOVE LUGGAGE COMPARTMENT TRIM INNER COVER RH 

    for Gasoline Model: Refer to PROCEDURE - Step 6

    for HV Model: Refer to PROCEDURE - Step 8

  19. REMOVE LUGGAGE COMPARTMENT TRIM INNER COVER LH 

    Refer to PROCEDURE - Step 9

  20. REMOVE REAR BUMPER UPPER RETAINER LH 
    1. Remove the rear combination light assembly LH.

      Refer to PROCEDURE - Step 10

    2. Remove the screw and rear bumper upper retainer LH.
      GTY867737Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  21. REMOVE REAR BUMPER UPPER RETAINER RH 

    HINT: 

    Use the same procedure as for the LH side.

  22. REMOVE REAR BUMPER SIDE SEAL LH 
    1. Remove the 2 grommets.
      GTY867743Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Remove the 2 clips and rear bumper side seal LH.
      GTY867740Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  23. REMOVE REAR BUMPER SIDE SEAL RH 
    1. Remove the 2 grommets.
      GTY867741Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. for Gasoline Model:
      GTY913182Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *A for HV Model
      1. Remove the 2 clips and rear bumper side seal RH.
    3. for HV Model:
      1. Remove the 3 clips and rear bumper side seal RH.
  24. REMOVE REAR BUMPER ENERGY ABSORBER 
    1. Disengage the 2 guides to remove the rear bumper energy absorber as shown in the illustration.
      GTY854744Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction
  25. REMOVE REAR BUMPER REINFORCEMENT 
    1. Remove the 6 bolts and rear bumper reinforcement.
      GTY867672Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals