LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2021 >> 4Runner Venture >> Repair and Diagnosis >> Accessories & Equipment >> Gauges & Instrument Panels >> Meter / Gauge System - Diagnostics - Introduction (2 Of 2) >> Meter / Gauge System >> Data List / Active Test [08/2015 - 08/2019] >> Data List / Active Test [08/2015 - 08/2019]

Data List / Active Test [08/2015 - 08/2019]

  1. DATA LIST 

    Using the Techstream to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.

    NOTE:

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

    1. Warm up the engine.
    2. Turn the ignition switch off.
    3. Connect the Techstream to the DLC3.
    4. Turn the ignition switch to ON.
    5. Turn the Techstream on.
    6. Enter the following menus:
      1. for Combination Meter: Body Electrical / Combination Meter / Data List
      2. for ABS/VSC/TRAC: Chassis / ABS/VSC/TRAC / Data List
      3. for Engine and ECT: Powertrain / Engine and ECT / Data List
    7. Check the values by referring to the table below.
      COMBINATION METER

      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      Tail Cancel SW TAIL cancel switch condition / OFF or ON OFF: TAIL cancel switch off
      ON: TAIL cancel switch on      		 -
      ODO/TRIP Change SW ODO/TRIP switch condition / OFF or ON OFF: ODO/TRIP switch not pushed
      ON: ODO/TRIP switch pushed      		 -
      P-Seatbelt Buckle SW Front passenger side seat belt warning light request signal / OFF or ON OFF: Tongue plate (for front passenger side) not inserted
      ON: Tongue plate (for front passenger side) inserted      		 -
      Vehicle Speed Meter Vehicle speed / Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) Almost same as actual vehicle speed (when driving) -
      Engine Rpm Engine speed / Min.: 0 rpm, Max.: 12800 rpm 600 to 700 rpm (When idling) -
      Coolant Temperature Engine coolant temperature / 16 to 127°C (60.8 to 260.6°F) After warming up: 80 to 95°C (176 to 203°F) -
      Washer Switch*1 Washer fluid level warning switch / OFF or ON OFF: Washer fluid level not low
      ON: Washer fluid level low      		 -
      Multi Display Select Switch DISP switch in the steering pad switch assembly / OFF or ON OFF: DISP switch in the steering pad switch assembly not pressed
      ON: DISP switch in the steering pad switch assembly pressed      		 -
      +B Voltage Value Battery voltage / Min.: 0 V, Max.: 25.5 V 11 to 14 V -
      Integrated value for Maintenance*2 Oil maintenance warning value / Min.: 0, Max.: 25500 (mile) Driving distance after performing oil maintenance resetting procedure displayed If the value is 5000 (miles) or more, perform the oil maintenance resetting procedure after changing the oil.
      Fuel Input Fuel input signal / Min.: 0, Max. 127.5 Current fuel level displayed Unit: Liters
      Ambient Temperature Outside temperature/Min.: -40°C (-40°F), Max.: 50°C (122°F) Almost the same as actual outside temperature The temperature displayed on the multi-information display is -40 to 50°C (-40 to 122°F).
      Rheostat value Light control rheostat switch input/Min.: 0, Max.: 100 Light control rheostat switch fully turned downward (0) → fully turned upward (100) Unit: %
      TPMS Operation State Condition of tire pressure warning system / ON, OFF, or Unknown OFF: Tire pressure warning system has not operated
      ON: Tire pressure warning system operated
      Unknown: Wire harness between combination meter assembly and tire pressure warning ECU open      		 -
      Oil Pressure Switch Oil pressure switch / OFF or ON OFF: Engine oil pressure low
      ON: Engine oil pressure not low      		 -
      Intuitive P/A (FR) No. 1 ultrasonic sensor condition / NG or OK NG: Sensor is frozen or sensor circuit is open
      OK: Normal      		 -
      Intuitive P/A (FL) No. 1 ultrasonic sensor condition / NG or OK NG: Sensor is frozen or sensor circuit is open
      OK: Normal      		 -
      Intuitive P/A (RR) No. 1 ultrasonic sensor condition / NG or OK NG: Sensor is frozen or sensor circuit is open
      OK: Normal      		 -
      Intuitive P/A (RC) No. 1 ultrasonic sensor condition / NG or OK NG: Sensor is frozen or sensor circuit is open
      OK: Normal      		 -
      Intuitive P/A (RL) No. 1 ultrasonic sensor condition / NG or OK NG: Sensor is frozen or sensor circuit is open
      OK: Normal      		 -
      Driver Side Seatbelt Warning Buzzer Condition of driver side seat belt warning buzzer / OFF or ON ON: Driver side seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when driver side seat belt unfastened
      OFF: Driver side seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when driver side seat belt unfastened      		 The customized setting of the driver side seat belt warning buzzer is displayed.
      P-Seatbelt Warning Buzzer Condition of front passenger side seat belt warning buzzer / OFF or ON ON: Front passenger side seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when front passenger side seat belt unfastened
      OFF: Front passenger side seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when front passenger side seat belt unfastened      		 The customized setting of the front passenger side seat belt warning buzzer is displayed.
      ECO Drive Indicator Zone Condition of eco driving indicator zone display in the multi-information display/OFF or ON ON: Eco driving indicator zone display in the multi-information display is enabled.
      OFF: Eco driving indicator zone display in the multi-information display is disabled.      		 -
      Number of Trouble Code Number of DTCs currently stored 0 -
      1. *1: w/ Level Warning Switch Assembly
      2. *2: for U.S.A.

      HINT: 

      Although the item is displayed on the Techstream, the vehicle may not have the indicator, warning, buzzer or display.

      ABS/VSC/TRAC

      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      FR Wheel Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed measured using a speedometer tester -
      FL Wheel Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed measured using a speedometer tester -
      RR Wheel Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed measured using a speedometer tester -
      RL Wheel Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed measured using a speedometer tester -
      Vehicle Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed measured using a speedometer tester -
      ENGINE AND ECT

      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      Engine Speed Engine speed/Min.: 0 rpm, Max.: 16383 rpm 600 to 700 rpm (When idling) -
      Coolant Temp Engine coolant temperature/Min.: -40°C (-40°F), Max: 215°C (419°F) 80 to 100°C (176 to 212°F): After warming up
      • If the value is -40°C (-40°F), the sensor circuit is open.
      • If the value is 140°C (284°F) or more, the sensor circuit is shorted.
  2. ACTIVE TEST 

    Using the Techstream to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.

    1. Connect the Techstream to the DLC3.
    2. Turn the ignition switch to ON.
    3. Turn the Techstream on.
    4. Enter the following menus: Body Electrical / Combination Meter / Active Test.
    5. Check the operation by referring to the table below.
      COMBINATION METER

      Tester Display Test Part Control Range Diagnostic Note
      Speed Meter Operation Speedometer 0, 40, 80, 120, 160, 200 mph*1 Acceptable range (mph): [Control range → Speedometer display]
      • 40 → 39.7 to 42.5
      • 80 → 79.5 to 84

      Confirm that the vehicle is stopped with the engine idling.
      0, 40, 80, 120, 160, 200 km/h*2 Acceptable range (km/h): [Control range → Speedometer display]
      • 40 → 38.9 to 43.4
      • 80 → 79.8 to 84.8
      • 120 → 119.1 to 125.9
      • 160 → 162 to 167

      Confirm that the vehicle is stopped with the engine idling.
      Tacho Meter Operation Tachometer 0, 1000, 2000, 3000, 4000, 5000, 6000, 7000 (rpm) Confirm that the vehicle is stopped with the engine idling.
      Fuel Meter Operation Fuel receiver gauge OFF, Sender E, Empty, Warning, 1/4, 1/2, 3/4, Full, Sender F Confirm that the vehicle is stopped with the engine idling.
      A/T Indicator Operation 1 A/T shift indicator light (D, P, N. R, 4, 3, 2, L) P, R, N, D, 4 (M), 3 (M), 2, L Confirm that the vehicle is stopped with the engine idling.
      A/T Indicator Operation 2 A/T gear range indicator light (S, 6, 5) 5, Es Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Airbag SRS warning light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Doors All Open Door indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Driver Side Seat Belt Driver side seat belt warning light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp ABS ABS warning light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Charge Charge warning light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Slip Slip indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Beam High beam indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Head*1 Head indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Tail*2 Tail indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Fr FOG Front fog indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Fuel Fuel level warning light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      ACTIVE TRC Indicator*3 A-TRAC indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      VSC TRC Indicator TRC OFF/TRAC OFF indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Tire Pressure Warning System Tire pressure warning light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Oil Pressure Oil pressure indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. ECONO Eco driving indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. 4WD*4,*5 4WD indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Cruise Cruise main indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Lamp Brake Brake warning light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. KEY*6 Smart key indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Master Warning Master warning light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Auto LSD*7 AUTO LSD indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Downhill Assist Control*8 Downhill assist control indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Ctr DIFF LOCK*4, *9 Center differential lock indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. Rr DIFF LOCK*10 Rear differential lock indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. 4LO*3 4LO indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. CRAWL*11 CRAWL indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. A/T P*4 A/T P indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. SET Cruise set indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Indicat. VSC OFF VSC OFF indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      KDSS Indicator*12 Kinetic dynamic suspension system indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      OFF Road Guidance Indicator*11 Multi terrain select indicator light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      PPS Indicator PPS warning light OFF / ON Confirm that the vehicle is stopped with the engine idling.
      Water Temperature Meter Operation Engine coolant temperature receiver gauge Low, Normal, High Confirm that the vehicle is stopped with the engine idling.
      Meter Display 1 Multi-information display OFF / All Confirm that the vehicle is stopped with the engine idling.
      1. *1: for U.S.A.
      2. *2: except U.S.A.
      3. *3: for 4WD
      4. *4: for VF2A Transfer
      5. *5: for VF2BM Transfer
      6. *6: Smart Key System
      7. *7: for 2WD
      8. *8: w/ Downhill Assist Control System
      9. *9: for VF4BM Transfer
      10. *10: w/ Rear Differential Lock
      11. *11: w/ CRAWL Control
      12. *12: w/ Kinetic Dynamic Suspension System
scientia non olet · About LEMON Manuals