DTC P33E0-1B: Hybrid/EV Battery Stack 1 Circuit Resistance Above Threshold; DTC P33E1-1B: Hybrid/EV Battery Stack 2 Circuit Resistance Above Threshold [06/2020 - ]: Procedure

1. Connect the Techstream to the DLC3.
2. Turn the ignition switch to ON.
3. Enter the following menus: Powertrain / HV Battery and Hybrid Control / Trouble Codes.
4. Check for DTCs.

   Powertrain > HV Battery > Trouble Codes 

   Powertrain > Hybrid Control > Trouble Codes 

   Result

   Result	Proceed to
   "P33E0-1B or P33E1-1B" only is output, or DTCs except the ones in the table below are also output.	A
   DTCs of hybrid battery system in the table below are output.	B
   DTCs of hybrid control system in the table below are output.	C

   System	Relevant DTC
   Hybrid battery system	P060A-47	Hybrid/EV Battery Energy Control Module Monitoring Processor Watchdog / Safety MCU Failure
   	P060B-49	Hybrid/EV Battery Energy Control Module A/D Processing Internal Electronic Failure
   	P0606-87	Hybrid/EV Battery Energy Control Module Processor to Monitoring Processor Missing Message
   Hybrid control system	P0A1F-94	Hybrid/EV Battery Energy Control Module Unexpected Operation

5. Turn the ignition switch off.

Result: 

B 

GO TO DTC CHART (HYBRID BATTERY SYSTEM) 

Refer to DIAGNOSTIC TROUBLE CODE CHART [06/2020 - ]

Result: 

C 

GO TO DTC CHART (HYBRID CONTROL SYSTEM) 

Refer to DIAGNOSTIC TROUBLE CODE CHART [06/2020 - 12/2021] , or refer to DIAGNOSTIC TROUBLE CODE CHART [12/2021 - 11/2024] , or refer to DIAGNOSTIC TROUBLE CODE CHART [11/2024 - ]

Result: 

A 

See step  2

1. Check the DTCs that were output when the vehicle was brought to the workshop.

   Result

   Result	Proceed to
   "P33E0-1B" is also output.	A
   "P33E1-1B" is also output.	B

Result: 

B 

See step  5

Result: 

A 

See step  3

1. Read the odometer to check the total distance the vehicle has been driven.

   Result

   Result		Proceed to
   Total distance driven is less than 200000 km (124280 mile)		A
   Total distance driven is 200000 km (124280 mile) or more	Current total distance driven - total distance driven when hybrid battery terminal block replaced = less than 200000 km (124280 mile) *1
   	Other than above	B

   HINT: 

   *1: If the hybrid battery terminal block has been replaced, use the total distance driven since it was replaced.

Result: 

A 

REPLACE NO. 1 HV SUPPLY STACK SUB-ASSEMBLY 

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

Result: 

B 

See step  4

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

Result

Result: 

NEXT 

REPLACE HYBRID BATTERY TERMINAL BLOCK 

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

1. Read the odometer to check the total distance the vehicle has been driven.

   Result

   Result		Proceed to
   Total distance driven is less than 200000 km (124280 mile)		A
   Total distance driven is 200000 km (124280 mile) or more	Current total distance driven - total distance driven when hybrid battery terminal block replaced = less than 200000 km (124280 mile) *1
   	Other than above	B

   HINT: 

   *1: If the hybrid battery terminal block has been replaced, use the total distance driven since it was replaced.

Result: 

A 

REPLACE NO. 2 HV SUPPLY STACK SUB-ASSEMBLY 

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

Result: 

B 

See step  6

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

Result

Result: 

NEXT 

REPLACE HYBRID BATTERY TERMINAL BLOCK 

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]