DTC P33DA-1E: Hybrid/EV Battery Stack 1 Circuit Resistance Out of Range; DTC P33DB-1E: Hybrid/EV Battery Stack 2 Circuit Resistance Out of Range [06/2020 - ]: Procedure

1. Connect the Techstream to the DLC3.
2. Turn the ignition switch to ON.
3. Enter the following menus: Powertrain / HV Battery / Trouble Codes.
4. Check if DTCs are output.

   Powertrain > HV Battery > Trouble Codes 

   Result

   Result	Proceed to
   "P33DA-1E" is output.	A
   "P33DB-1E" is output.	B

5. Turn the ignition switch off.

Result: 

B 

See step  4

Result: 

A 

See step  2

1. Read the odometer to check the total distance the vehicle has been driven.

   Result

   Result		Proceed to
   Total distance driven is less than 200000 km (124280 mile)		A
   Total distance driven is 200000 km (124280 mile) or more	Current total distance driven - total distance driven when hybrid battery terminal block replaced = less than 200000 km (124280 mile) *1
   	Other than above	B

   HINT: 

   *1: If the hybrid battery terminal block has been replaced, use the total distance driven since it was replaced.

Result: 

A 

REPLACE NO. 1 HV SUPPLY STACK SUB-ASSEMBLY 

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

Result: 

B 

See step  3

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

Result

Result: 

NEXT 

REPLACE HYBRID BATTERY TERMINAL BLOCK 

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

1. Read the odometer to check the total distance the vehicle has been driven.

   Result

   Result		Proceed to
   Total distance driven is less than 200000 km (124280 mile)		A
   Total distance driven is 200000 km (124280 mile) or more	Current total distance driven - total distance driven when hybrid battery terminal block replaced = less than 200000 km (124280 mile) *1
   	Other than above	B

   HINT: 

   *1: If the hybrid battery terminal block has been replaced, use the total distance driven since it was replaced.

Result: 

A 

REPLACE NO. 2 HV SUPPLY STACK SUB-ASSEMBLY 

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

Result: 

B 

See step  5

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]

Result

Result: 

NEXT 

REPLACE HYBRID BATTERY TERMINAL BLOCK 

Refer to REMOVAL [06/2020 - 08/2020] , or refer to REMOVAL [08/2020 - 12/2021] , or refer to REMOVAL [12/2021 - 10/2022] , or refer to REMOVAL [10/2022 - 10/2023] , or refer to REMOVAL [10/2023 - ]