LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2020 >> RAV4 LE, AWD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 13 (Hybrid Battery System (Lithium-Ion Battery) - Diagnostics - Introduction) >> HYBRID BATTERY SYSTEM (for LITHIUM-ION BATTERY) >> Vehicle Behavior Chart [06/2020 - ] >> Vehicle Behavior Chart [06/2020 - ]

Vehicle Behavior Chart [06/2020 - ]

WARNING: This page is about a different variant/trim than selected.
  1. VEHICLE BEHAVIOR CHART 
    1. Vehicle behavior categorized by DTC

      If a DTC is output, the vehicle behaves as follows.

      DTC No. Detection Item Vehicle Behavior when DTC is Output
      P0560-14 System Voltage (BATT) Circuit Short to Ground or Open Normal driving
      P0606-29 Hybrid/EV Battery Energy Control Module Processor to Monitoring Processor Signal Invalid
      • Reduced output power
      • Engine not stopped
      P0606-87 Hybrid/EV Battery Energy Control Module Processor to Monitoring Processor Missing Message
      • Reduced output power
      • Engine not stopped
      P060A-47 Hybrid/EV Battery Energy Control Module Monitoring Processor Watchdog / Safety MCU Failure
      • Reduced output power
      • Engine not stopped
      P060A-87 Hybrid/EV Battery Energy Control Module Processor from Monitoring Processor Missing Message
      • Reduced output power
      • Engine not stopped
      P060B-16 Hybrid/EV Battery Energy Control Module A/D Processing Circuit Voltage Below Threshold
      • Reduced output power
      • Engine not stopped
      P060B-49 Hybrid/EV Battery Energy Control Module A/D Processing Internal Electronic Failure
      • Reduced output power
      • Engine not stopped
      P062F-44 Hybrid/EV Battery Energy Control Module EEPROM Data Memory Failure Normal driving
      P062F-46 Hybrid/EV Battery Energy Control Module EEPROM Calibration / Parameter Memory Failure Normal driving
      P0A1D-94 Hybrid/EV Powertrain Control Module Unexpected Operation Hybrid system stopped
      P0A81-00 Hybrid/EV Battery Cooling Fan 1 Control Circuit High Normal driving
      P0A81-11 Hybrid/EV Battery Cooling Fan 1 Circuit Short to Ground Normal driving
      P0A81-15 Hybrid/EV Battery Cooling Fan 1 Circuit Short to Auxiliary Battery or Open Normal driving
      P0A81-4B Hybrid/EV Battery Cooling Fan 1 Over Temperature Normal driving
      P0A81-96 Hybrid/EV Battery Cooling Fan 1 Component Internal Failure Normal driving
      P0A81-98 Hybrid/EV Battery Cooling Fan 1 Component or System Over Temperature Normal driving
      P0A95-63 High Voltage Fuse Accumulated Load History Normal driving
      P0A9B-11 Hybrid/EV Battery Temperature Sensor "A" Circuit Short to Ground Normal driving
      P0A9B-15 Hybrid/EV Battery Temperature Sensor "A" Circuit Short to Auxiliary Battery or Open Normal driving
      P0A9B-1C Hybrid/EV Battery Temperature Sensor "A" Voltage Out of Range Normal driving
      P0A9B-2A Hybrid/EV Battery Temperature Sensor "A" Signal Stuck In Range Normal driving
      P0AAC-11 Hybrid/EV Battery Air Temperature Sensor "A" Circuit Short to Ground Normal driving
      P0AAC-15 Hybrid/EV Battery Air Temperature Sensor "A" Circuit Short to Auxiliary Battery or Open Normal driving
      P0ABF-11 Hybrid/EV Battery Current Sensor "A" Circuit Short to Ground
      • Reduced output power
      • Engine not stopped
      P0ABF-15 Hybrid/EV Battery Current Sensor "A" Circuit Short to Auxiliary Battery or Open
      • Reduced output power
      • Engine not stopped
      P0ABF-28 Hybrid/EV Battery Current Sensor "A" Signal Bias Level Out of Range / Zero Adjustment Failure
      • Reduced output power
      • Engine not stopped
      P0ABF-2A Hybrid/EV Battery Current Sensor "A" Signal Stuck In Range
      • Reduced output power
      • Engine not stopped
      P0AC5-11 Hybrid/EV Battery Temperature Sensor "B" Circuit Short to Ground Normal driving
      P0AC5-15 Hybrid/EV Battery Temperature Sensor "B" Circuit Short to Auxiliary Battery or Open Normal driving
      P0AC5-1C Hybrid/EV Battery Temperature Sensor "B" Voltage Out of Range Normal driving
      P0AC5-2A Hybrid/EV Battery Temperature Sensor "B" Signal Stuck In Range Normal driving
      P0ACA-11 Hybrid/EV Battery Temperature Sensor "C" Circuit Short to Ground Normal driving
      P0ACA-15 Hybrid/EV Battery Temperature Sensor "C" Circuit Short to Auxiliary Battery or Open Normal driving
      P0ACA-1C Hybrid/EV Battery Temperature Sensor "C" Voltage Out of Range Normal driving
      P0ACA-2A Hybrid/EV Battery Temperature Sensor "C" Signal Stuck In Range Normal driving
      P0AE8-11 Hybrid/EV Battery Temperature Sensor "D" Circuit Short to Ground Normal driving
      P0AE8-15 Hybrid/EV Battery Temperature Sensor "D" Circuit Short to Auxiliary Battery or Open Normal driving
      P0AE8-1C Hybrid/EV Battery Temperature Sensor "D" Voltage Out of Range Normal driving
      P0AE8-2A Hybrid/EV Battery Temperature Sensor "D" Signal Stuck In Range Normal driving
      P0B0E-11 Hybrid/EV Battery Current Sensor "B" Circuit Short to Ground
      • Reduced output power
      • Engine not stopped
      P0B0E-15 Hybrid/EV Battery Current Sensor "B" Circuit Short to Auxiliary Battery or Open
      • Reduced output power
      • Engine not stopped
      P0B13-62 Hybrid/EV Battery Current Sensor "A"/"B" Signal Compare Failure
      • Reduced output power
      • Engine not stopped
      P0BC2-11 Hybrid/EV Battery Temperature Sensor "E" Circuit Short to Ground Normal driving
      P0BC2-15 Hybrid/EV Battery Temperature Sensor "E" Circuit Short to Auxiliary Battery or Open Normal driving
      P0BC2-1C Hybrid/EV Battery Temperature Sensor "E" Voltage Out of Range Normal driving
      P0BC2-2A Hybrid/EV Battery Temperature Sensor "E" Signal Stuck In Range Normal driving
      P0C30-00 Hybrid/EV Battery State of Charge High
      • Greatly reduced output power
      • A driving range is limited
      • Engine always stopped
      P0C33-11 Hybrid/EV Battery Temperature Sensor "F" Circuit Short to Ground Normal driving
      P0C33-15 Hybrid/EV Battery Temperature Sensor "F" Circuit Short to Auxiliary Battery or Open Normal driving
      P0C33-1C Hybrid/EV Battery Temperature Sensor "F" Voltage Out of Range Normal driving
      P0C33-2A Hybrid/EV Battery Temperature Sensor "F" Signal Stuck In Range Normal driving
      P0E2D-00 Hybrid/EV Battery Energy Control Module Hybrid/EV Battery Monitor Performance
      • Reduced output power
      • Engine not stopped
      P1A00-1C Hybrid Battery Stack 2 Cell Voltage Detection Voltage Out of Range
      • Reduced output power
      • Engine not stopped
      P1A60-17 Hybrid/EV Battery Stack 2 Cell Circuit Voltage Above Threshold
      • Reduced output power
      • Engine not stopped
      P1A61-16 Hybrid/EV Battery Stack 2 Cell Circuit Voltage Below Threshold
      • Reduced output power
      • Engine not stopped
      P1A80-00 Hybrid/EV Battery Stack 1 Delta SOC High Normal driving
      P1A81-00 Hybrid/EV Battery Stack 1 Delta SOC High (Extreme)
      • Reduced output power
      • Engine not stopped
      P1A85-00 Hybrid/EV Battery Stack 2 Delta SOC High Normal driving
      P1A86-00 Hybrid/EV Battery Stack 2 Delta SOC High (Extreme)
      • Reduced output power
      • Engine not stopped
      P1AFC-00 System Voltage (AM) Circuit Voltage Below Threshold Hybrid system stopped
      P1AFD-00 Flying Capacitor Circuit Voltage Out of Range
      • Reduced output power
      • Engine not stopped
      P1AFD-1C Flying Capacitor/Internal Control Module Hybrid/EV Battery Monitor Voltage Out of Range
      • Reduced output power
      • Engine not stopped
      P1AFF-00 Hybrid/EV Battery ECU Multiple Reset Hybrid system stopped
      P1C85-49 High Voltage Power Resource Internal Electronic Failure Hybrid system stopped
      P1C9F-11 Hybrid/EV Battery Current Sensor for Driving Control Circuit Short to Ground Normal driving
      P1C9F-15 Hybrid/EV Battery Current Sensor for Driving Control Circuit Short to Auxiliary Battery or Open Normal driving
      P1C9F-1C Hybrid/EV Battery Current Sensor for Driving Control Voltage Out of Range Normal driving
      P1CBB-12 Hybrid/EV Battery Current Sensor Power Supply Circuit Short to Auxiliary Battery
      • Reduced output power
      • Engine not stopped
      P1CBB-14 Hybrid/EV Battery Current Sensor Power Supply Circuit Short to Ground or Open
      • Reduced output power
      • Engine not stopped
      P1CC8-1E Hybrid/EV Battery Stack 1 Voltage Difference Out of Range
      • Reduced output power
      • Engine not stopped
      P1CC9-1E Hybrid/EV Battery Stack 2 Voltage Difference Out of Range
      • Reduced output power
      • Engine not stopped
      P3000-00 Hybrid/EV Battery Discharge Control Malfunction Hybrid system stopped
      P3000-16 Hybrid/EV Battery Control System Circuit Voltage Below Threshold Hybrid system stopped
      P3000-4B Hybrid/EV Battery Control System Over Temperature Hybrid system stopped
      P301A-1C Hybrid Battery Stack 1 Cell Voltage Detection Voltage Out of Range
      • Reduced output power
      • Engine not stopped
      P3065-62 Hybrid/EV Battery Temperature Sensor "Group 1" Signal Compare Failure Normal driving
      P306A-62 Hybrid/EV Battery Temperature Sensor "Group 2" Signal Compare Failure Normal driving
      P31AA-17 Hybrid/EV Battery Stack 1 Cell Circuit Voltage Above Threshold
      • Reduced output power
      • Engine not stopped
      P31AB-16 Hybrid/EV Battery Stack 1 Cell Circuit Voltage Below Threshold
      • Reduced output power
      • Engine not stopped
      P31B3-00 Hybrid/EV Battery Voltage High
      • Reduced output power
      • Engine not stopped
      P31B4-00 Extreme Hybrid/EV Battery Charging Current Hybrid system stopped
      P31B5-49 Hybrid/EV Battery Internal Electronic Failure Hybrid system stopped
      P33DA-1E Hybrid/EV Battery Stack 1 Circuit Resistance Out of Range
      • Reduced output power
      • Engine not stopped
      P33DB-1E Hybrid/EV Battery Stack 2 Circuit Resistance Out of Range
      • Reduced output power
      • Engine not stopped
      P33E0-1B Hybrid/EV Battery Stack 1 Circuit Resistance Above Threshold
      • Reduced output power
      • Engine not stopped
      P33E1-1B Hybrid/EV Battery Stack 2 Circuit Resistance Above Threshold
      • Reduced output power
      • Engine not stopped
      P33EC-16 (Extreme) Hybrid/EV Battery Stack 1 Cell Circuit Voltage Below Threshold
      • Reduced output power
      • Engine not stopped
      P33ED-16 (Extreme) Hybrid/EV Battery Stack 2 Cell Circuit Voltage Below Threshold
      • Reduced output power
      • Engine not stopped
      U0100-87 Lost Communication with ECM/PCM "A" Missing Message Normal driving
      U0293-87 Lost Communication with Hybrid/EV Powertrain Control Module Missing Message Normal driving
      U1150-87 Lost Communication with Hybrid Powertrain Control Module (Hybrid/EV Battery Local Bus) Missing Message
      • Reduced output power
      • Engine not stopped
    2. Relationship between the above and the multi-information display
      Multi-information Display Vehicle Behavior
      Visit Your Dealer Normal driving
      Driving: 
      1. Hybrid System Stopped Stop in a Safe Place

      Stop: 
      1. Shift to [P] See Owner's Manual
      		 Hybrid system stopped
      Driving: 
      1. Hybrid System Stopped Stop in a Safe Place

      Stop: 
      1. Shift to [P] See Owner's Manual
      1. Normal driving
      2. When malfunction continues
        • Hybrid system stopped
      1. Normal driving
      Driving: 
      • Stop in a safe place See owner's manual
      • Stop in a safe place within "◦" km

      Stop: 
      1. Shift to [P] See Owner's Manual
      		 A Driving range is limited
      Output Power Reduced Visit Your Dealer Reduced output power
      Output Power Greatly Reduced Visit Your Dealer Greatly reduced output power
      Driving: 
      1. Output Power Reduced Avoid Shifting to [N]

      Stop: 
      1. Avoid Shifting to [N] Visit Your Dealer
      • Reduced output power
      • Engine does not stop

      "◦": Varies depending on the remaining driving range.

scientia non olet · About LEMON Manuals