LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2019 >> Highlander LE Plus, FWD >> Repair and Diagnosis >> Drivelines & Axles >> Wheel Hubs >> Axle Hubs, Steering Knuckle & Differential (Service Information) (Except Hybrid) >> Differential Oil >> Replacement [12/2013 - ] >> Procedure

Replacement [12/2013 - ]: Procedure

  1. DRAIN DIFFERENTIAL OIL 
    1. Using a 10 mm hexagon wrench, remove the differential inspection plug and gasket.
      GTY423920Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Using a 10 mm hexagon wrench, remove the rear differential drain plug and gasket to drain the differential oil.
      GTY450424Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  2. INSTALL REAR DIFFERENTIAL DRAIN PLUG 
    1. Using a 10 mm hexagon wrench, install a new gasket and the rear differential drain plug.

      Torque: 39 N*m (398 kgf*cm, 29 ft.*lbf) 

      GTY450424Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  3. ADD DIFFERENTIAL OIL 
    1. Add differential oil so that the oil level is between 0 to 5 mm (0 to 0.196 in.) from the bottom lip of the differential inspection plug opening.
      GTY363612Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *a 0 to 5 mm (0 to 0.196 in.)

      Oil Type

      Toyota genuine differential gear oil LT 75W-85 GL-5 or equivalent

      Standard Differential Oil Capacity

      0.45 to 0.55 liters (0.48 to 0.58 US qts., 0.40 to 0.48 Imp.qts.)

      NOTE:
      • Too much or too little oil will lead to differential problems.
      • After changing the oil, drive the vehicle and then check the oil level again.
  4. INSPECT DIFFERENTIAL OIL 
    1. Check that the oil level is between 0 to 5 mm (0 and 0.196 in.) from the bottom lip of the differential inspection plug opening.
      GTY363612Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *a 0 to 5 mm (0 to 0.196 in.)
    2. Inspect for oil leaks if the oil level is low.
  5. INSTALL DIFFERENTIAL INSPECTION PLUG 
    1. Using a 10 mm hexagon wrench, install a new gasket and the differential inspection plug.
      GTY423920Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

      Torque: 39 N*m (398 kgf*cm, 29 ft.*lbf) 

scientia non olet · About LEMON Manuals