LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2018 >> Highlander XLE, AWD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 3 (Automatic Transmission (UA80E) - Service Information (1 Of 2)) >> Oil Cooler >> Removal [11/2016 - ] >> Procedure

Removal [11/2016 - ]: Procedure

WARNING: This page is about a different variant/trim than selected.
  1. PRECAUTION 
    NOTE:

    After turning the ignition switch off, waiting time may be required before disconnecting the cable from the negative (-) battery terminal. Therefore, make sure to read the disconnecting the cable from the negative (-) battery terminal notices before proceeding with work.

    Refer to PRECAUTION [11/2016 - ]

  2. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL 
    NOTE:

    When disconnecting the cable, some systems need to be initialized after the cable is reconnected.

    Refer to INITIALIZATION [11/2016 - ]

  3. REMOVE FRONT WHEEL LH 
  4. REMOVE NO. 1 ENGINE UNDER COVER 

    Refer to PROCEDURE - Step 8

  5. REMOVE FRONT FENDER APRON SEAL LH 

    Refer to PROCEDURE - Step 13

  6. DRAIN ENGINE COOLANT 

    Refer to PROCEDURE - Step 1

  7. REMOVE RADIATOR SIDE DEFLECTOR SEAL LH 

    Refer to PROCEDURE - Step 1

  8. REMOVE RADIATOR SIDE SEAL RH 

    Refer to PROCEDURE - Step 2

  9. REMOVE COOL AIR INTAKE DUCT SEAL 

    Refer to PROCEDURE - Step 3

  10. REMOVE INLET AIR CLEANER ASSEMBLY 

    Refer to PROCEDURE - Step 27

  11. REMOVE AIR CLEANER ASSEMBLY WITH AIR CLEANER HOSE 

    Refer to PROCEDURE - Step 28

  12. REMOVE BATTERY 

    Refer to PROCEDURE - Step 26

  13. DISCONNECT NO. 4 WATER BY-PASS HOSE 
    1. Slide the clip and disconnect the No. 4 water by-pass hose from the transmission oil cooler.
      NOTE:

      Use a container to catch any coolant which flows out of the No. 4 water by-pass hose and transmission oil cooler.

      GTY738850Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  14. DISCONNECT NO. 3 WATER BY-PASS HOSE 
    1. Slide the clip and disconnect the No. 3 water by-pass hose from the transmission oil cooler.
      NOTE:

      Use a container to catch any coolant which flows out of the No. 3 water by-pass hose and transmission oil cooler.

      GTY722560Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  15. DISCONNECT INLET NO. 2 OIL COOLER HOSE 
    1. Slide the clip and disconnect the inlet No. 2 oil cooler hose from the transmission oil cooler.
      NOTE:

      Use a container to catch any automatic transaxle fluid which flows out of the inlet No. 2 oil cooler hose and transmission oil cooler.

      GTY694248Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  16. DISCONNECT OUTLET NO. 3 OIL COOLER HOSE 
    1. Slide the clip and disconnect the outlet No. 3 oil cooler hose from the transmission oil cooler.
      NOTE:

      Use a container to catch any automatic transaxle fluid which flows out of the outlet No. 3 oil cooler hose and transmission oil cooler.

      GTY714267Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  17. DISCONNECT OUTLET NO. 1 OIL COOLER HOSE 
    1. Remove the transmission oil cooler tube clamp.
      GTY728749Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *1 Transmission Oil Cooler Tube Clamp
    2. Slide the clip and disconnect the outlet No. 1 oil cooler hose from the No. 1 oil cooler tube sub-assembly without hose.
  18. DISCONNECT NO. 1 TRANSMISSION OIL COOLER HOSE 
    1. Slide the clip and disconnect the No. 1 transmission oil cooler hose from the oil cooler union sub-assembly.
      GTY694254Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  19. REMOVE NO. 1 OIL COOLER TUBE SUB-ASSEMBLY WITHOUT HOSE 
    1. Slide the clip and disconnect the inlet No. 1 oil cooler hose from the connector tube.
      GTY686203Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *1 Inlet No. 1 Oil Cooler Hose
      NOTE:

      Use a container to catch any automatic transaxle fluid which flows out of the inlet No. 1 oil cooler hose and connector tube.

    2. Remove the 2 bolts and No. 1 oil cooler tube sub-assembly without hose from the automatic transaxle case sub-assembly and engine mounting bracket LH.
    3. Slide the 3 clips and remove the inlet No. 1 oil cooler hose, inlet No. 2 oil cooler hose and outlet No. 3 oil cooler hose from the No. 1 oil cooler tube sub-assembly without hose.
      GTY705015Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *1 No. 1 Oil Cooler Tube Sub-assembly without Hose
      *2 Inlet No. 1 Oil Cooler Hose
      *3 Inlet No. 2 Oil Cooler Hose
      *4 Outlet No. 3 Oil Cooler Hose
  20. REMOVE TRANSMISSION OIL COOLER 
    1. Remove the 3 bolts.
      GTY694251Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Disengage the hook to remove the transmission oil cooler from the automatic transaxle case sub-assembly.
      NOTE:

      Use a container to catch any coolant and automatic transaxle fluid which flows out of the transmission oil cooler.

  21. REMOVE TRANSMISSION OIL THERMOSTAT 
    1. Slide the 2 clips and remove the No. 1 transmission oil cooler hose and outlet No. 1 oil cooler hose from the transmission oil thermostat.
      GTY732997Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *1 No. 1 Transmission Oil Cooler Hose
      *2 Outlet No. 1 Oil Cooler Hose
      NOTE:

      Use a container to catch any automatic transaxle fluid which flows out of the transmission oil thermostat, No. 1 transmission oil cooler hose and outlet No. 1 oil cooler hose.

    2. Slide the 2 clips and disconnect the No. 2 transmission oil cooler hose and outlet No. 2 oil cooler hose from the transmission oil thermostat.
      GTY719263Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *1 No. 2 Transmission Oil Cooler Hose
      *2 Outlet No. 2 Oil Cooler Hose
      NOTE:

      Use a container to catch any automatic transaxle fluid which flows out of the transmission oil thermostat, No. 2 transmission oil cooler hose and outlet No. 2 oil cooler hose.

    3. Remove the bolt and transmission oil thermostat from the oil cooler stay.
      NOTE:

      Use a container to catch any automatic transaxle fluid which flows out of the transmission oil thermostat.

      GTY718654Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals