LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2016 >> RAV4 SE, AWD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 1 (Automatic Transmission (U760E) - Service Information (1 Of 2)) >> Differential Oil Seal >> Replacement [12/2012 - ] >> Procedure

Replacement [12/2012 - ]: Procedure

WARNING: This page is about a different variant/trim than selected.
  1. REMOVE FRONT DRIVE SHAFT ASSEMBLY 

    Refer to REMOVAL [12/2012 - ]

  2. REMOVE TRANSAXLE CASE OIL SEAL LH 
    1. Using SST, tap out the transaxle case oil seal LH.
      GTY383024Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      • SST: 09308-00010 
  3. REMOVE TRANSAXLE CASE OIL SEAL RH 
    1. Using SST, tap out the transaxle case oil seal RH.
      GTY361141Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      • SST: 09308-00010 
  4. INSTALL TRANSAXLE CASE OIL SEAL RH 
    1. Using SST and a hammer, tap in a new transaxle case oil seal RH.
      GTY362174Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      • SST: 09316-60011 
        1. 09316-00011

      Oil seal driven in depth

      -0.5 to 0.5 mm (-0.0197 to 0.0197 in.)

      NOTE:

      Check that the transaxle case oil seal RH is installed in the correct direction.

    2. Coat the lip of the transaxle case oil seal RH with MP grease.
  5. INSTALL TRANSAXLE CASE OIL SEAL LH 
    1. Using SST and a hammer, tap in a new transaxle case oil seal LH.
      GTY371721Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      • SST: 09316-10010 
      • SST: 09950-70010 
        1. 09951-07150

      Oil seal driven in depth

      -0.5 to 0.5 mm (-0.0197 to 0.0197 in.)

      NOTE:

      Check that the transaxle case oil seal LH is installed in the correct direction.

    2. Coat the lip of the transaxle case oil seal LH with MP grease.
  6. INSTALL FRONT DRIVE SHAFT ASSEMBLY 

    Refer to INSTALLATION [12/2012 - 08/2016] or INSTALLATION [08/2016 - ]

scientia non olet · About LEMON Manuals