LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2016 >> Highlander Hybrid Limited >> Repair and Diagnosis >> External Pages >> Different car >> Section 65 (Fuel System (2GR-FXS) - Service Information - (Hybrid)) >> Fuel Pump Ecu >> Removal [11/2016 - ] >> Procedure

Removal [11/2016 - ]: Procedure

WARNING: This page is about a different car, the 2019 Toyota Highlander, 2018 Toyota Highlander, and 2017 Toyota Highlander. However, it is still accessible from the selected car via links, so may be relevant.
  1. REMOVE DECK BOARD ASSEMBLY 

    Refer to PROCEDURE - Step 1

  2. REMOVE NO. 3 DECK BOARD SUB-ASSEMBLY 

    Refer to PROCEDURE - Step 2

  3. REMOVE DECK SIDE TRIM BOX LH 

    Refer to PROCEDURE - Step 3

  4. REMOVE REAR DECK FLOOR BOX 

    Refer to PROCEDURE - Step 4

  5. REMOVE REAR FLOOR FINISH PLATE 

    Refer to PROCEDURE - Step 5

  6. REMOVE REAR NO. 2 SEAT ASSEMBLY 

    Refer to REMOVAL [11/2016 - ]

  7. REMOVE REAR OUTER SEAT TRACK BRACKET COVER LH 

    Refer to PROCEDURE - Step 4

  8. REMOVE REAR DOOR SCUFF PANEL LH 

    Refer to PROCEDURE - Step 12

  9. REMOVE REAR DOOR SCUFF PLATE LH 

    Refer to PROCEDURE - Step 13

  10. DISCONNECT REAR DOOR OPENING TRIM WEATHERSTRIP LH 

    Refer to PROCEDURE - Step 11

  11. REMOVE FRONT DECK SIDE TRIM COVER LH 

    Refer to PROCEDURE - Step 28

  12. DISCONNECT REAR NO. 1 SEAT OUTER BELT ASSEMBLY LH 

    Refer to PROCEDURE - Step 13

  13. REMOVE NO. 2 DECK SIDE TRIM COVER 

    Refer to PROCEDURE - Step 30

  14. DISCONNECT REAR NO. 2 SEAT OUTER BELT ASSEMBLY LH 

    Refer to PROCEDURE - Step 16

  15. REMOVE DECK TRIM POCKET COVER (for LH Side) 

    Refer to PROCEDURE - Step 33

  16. REMOVE NO. 1 LUGGAGE COMPARTMENT TRIM HOOK (for LH Side) 

    Refer to PROCEDURE - Step 34

  17. REMOVE ROPE HOOK (for LH Side) 

    Refer to PROCEDURE - Step 35

  18. REMOVE DECK TRIM SIDE PANEL ASSEMBLY LH 

    Refer to PROCEDURE - Step 36

  19. REMOVE FUEL PUMP CONTROL ECU 
    1. Disconnect the 2 fuel pump control ECU connectors.
      GTY721820Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Remove the 2 nuts and fuel pump control ECU from the vehicle body.
      NOTE:

      Do not reuse the fuel pump control ECU if it has been dropped or subjected to a severe impact.

  20. REMOVE FUEL PUMP CONTROL ECU BRACKET 
    1. Remove the 2 bolts and fuel pump control ECU bracket from the fuel pump control ECU.
      GTY721819Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals