LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2016 >> Highlander Hybrid Limited >> Repair and Diagnosis >> Accessories & Equipment >> Wiper/Washer Systems >> Wiper System / Washer System (Service Information) (Hybrid) >> Washer Motor >> Removal [02/2014 - ] >> Procedure

Removal [02/2014 - ]: Procedure

  1. REMOVE FRONT FENDER WHEEL OPENING MOULDING SUB-ASSEMBLY RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to REMOVAL [02/2014 - ]

  2. REMOVE FRONT WHEEL RH 
  3. REMOVE FRONT WHEEL OPENING EXTENSION PAD RH 
    1. Remove the 3 screws and front wheel opening extension pad RH.
      GTY455169Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  4. REMOVE FRONT FENDER LINER RH 
    1. Remove the clip (A).
      GTY425233Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *a Clip (A)
      *b Clip (B)
      *c Clip (C)
    2. Remove the 4 clips (B).
    3. w/o Mudguard:
      1. Remove the clip (C).
    4. Remove the 2 grommets.
      GTY445829Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    5. Remove the bolt.
      GTY453048Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *a Screw (A)
      *b Screw (B)
      *c Bolt
    6. Remove the 2 screws (A).
    7. Remove the 5 screws (B) and front fender liner RH.
  5. DRAIN WASHER FLUID 
    1. Disconnect the washer hose from the windshield washer motor and pump assembly, and drain the washer fluid.
      GTY445830Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

      HINT: 

      Use a container to collect the washer fluid.

  6. REMOVE WASHER MOTOR AND PUMP ASSEMBLY 
    1. Disconnect the connector.
      GTY445828Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Remove the washer motor and pump assembly as shown in the illustration.
scientia non olet · About LEMON Manuals