LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2015 >> RAV4 LE, AWD >> Repair and Diagnosis >> Transmission >> Transfer Case >> Transfer Case (Service Information) >> Transfer Oil >> Replacement [12/2012 - ] >> Procedure

Replacement [12/2012 - ]: Procedure

  1. DRAIN TRANSFER OIL 
    1. Stop the vehicle on a level surface.
    2. Using a 10 mm straight hexagon wrench and 10 x 12 mm long offset wrench, remove the No. 2 transfer case plug (for filler) and gasket.
      GTY366016Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *1 No. 2 Transfer Case Plug (for filler)
      *2 Transfer Drain Plug
    3. Using a 10 mm hexagon socket wrench, remove the transfer drain plug and gasket and drain the transfer oil.
    4. Using a 10 mm hexagon socket wrench, install a new gasket and the drain plug.

      Torque: 39 N*m (398 kgf*cm, 29 ft.*lbf) 

  2. ADD TRANSFER OIL 
    1. Using a 10 mm straight hexagon wrench and 10 x 12 mm long offset wrench, remove the No. 2 transfer case plug (for filler) and gasket.
    2. Add transfer oil.

      Oil grade

      Toyota Genuine Differential gear oil LT API GL-5 or equivalent

      Viscosity

      SAE 75W-85

    3. Pour oil so that the oil level is between 0 to 5.0 mm (0 to 0.196 in.) from the bottom lip of the No. 2 transfer case plug (for filler) hole.
      GTY369781Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *a 0 to 5.0 mm (0 to 0.196 in.)
      NOTE:
      • When adding oil, pour it slowly.
      • Add oil a little at a time, waiting several minutes between each addition of oil.
      • Too much or too little oil will lead to transfer problems.

      Standard Capacity

      0.40 to 0.50 liters (0.43 to 0.52 US qts, 0.36 to 0.44 Imp.qts)

    4. Wait approximately 5 minutes and check that the oil level has not changed.
    5. Using a 10 mm straight hexagon wrench, 12 mm hexagon socket wrench and 10 x 12 mm long offset wrench, install a new gasket into the No. 2 transfer case plug (for filler) and then install the No. 2 transfer case plug (for filler).
      GTY374291Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *1 10 mm Straight Hexagon Wrench
      *2 12 mm Hexagon Socket Wrench
      *3 10 x 12 mm Long Offset Wrench

      Torque: 39 N*m (398 kgf*cm, 28 ft.*lbf) 

      NOTE:
      • Use the formula to calculate special torque values for situations where a offset wrench is combined with a torque wrench (Refer to PRECAUTION [12/2012 - ] ).
      • After adding oil, drive the vehicle and recheck the oil level.

      HINT: 

      When tightening, combine the offset wrench with the torque wrench so that they are in a straight line.