LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2009 >> Matrix S, FWD, Automatic >> Repair and Diagnosis >> Engine Mechanical >> Mechanical >> Engine Mechanical (2AZ-FE) >> Engine Unit >> Removal

Engine Unit: Removal

  1. REMOVE FUEL DELIVERY PIPE SUB-ASSEMBLY  (See REMOVAL )
  2. REMOVE FUEL INJECTOR ASSEMBLY  (See REMOVAL )
  3. REMOVE INTAKE MANIFOLD  (See REMOVAL )
  4. REMOVE NO. 1 INTAKE MANIFOLD INSULATOR 
    1. Remove the No. 1 intake manifold insulator.
      Fig 1: Identifying No. 1 Intake Manifold Insulator
      G05386990Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  5. REMOVE NO. 1 EXHAUST MANIFOLD HEAT INSULATOR  (See REMOVAL )
  6. REMOVE MANIFOLD STAY  (See REMOVAL )
  7. REMOVE NO. 2 MANIFOLD STAY  (See REMOVAL )
  8. REMOVE EXHAUST MANIFOLD CONVERTER SUB-ASSEMBLY  (See REMOVAL )
  9. REMOVE WATER INLET  (See REMOVAL )
  10. REMOVE THERMOSTAT  (See REMOVAL )
  11. REMOVE ENGINE OIL DIPSTICK 
  12. REMOVE ENGINE OIL DIPSTICK GUIDE  (See REMOVAL )
  13. REMOVE NO. 1 WATER BY-PASS PIPE 
    1. Remove the bolt and 2 nuts, then remove the No. 1 water by-pass pipe.
    2. Remove the gasket.
  14. REMOVE IGNITION COIL ASSEMBLY  (See REMOVAL )
  15. REMOVE KNOCK SENSOR  (See REMOVAL )
  16. REMOVE OIL PRESSURE SWITCH  (See OIL PRESSURE SWITCH )
    Fig 2: Locating No. 1 Water By-Pass Pipe Nuts And Bolts
    G05387363Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  17. REMOVE ENGINE COOLANT TEMPERATURE SENSOR  (See REMOVAL )
  18. REMOVE RADIO SETTING CONDENSER 
    1. Remove the bolt and radio setting condenser.
    Fig 3: Locating Radio Setting Condenser
    G04974190Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals