LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2009 >> Highlander Limited, FWD >> Repair and Diagnosis >> Accessories & Equipment >> Interior/Illumination Lights >> Lighting System (Except Hybrid) >> HIGH MOUNTED STOP LIGHT ASSEMBLY (for Rear Spoiler without Press Line) >> Removal

HIGH MOUNTED STOP LIGHT ASSEMBLY (for Rear Spoiler without Press Line): Removal

  1. PRECAUTION 
    NOTE:
    • Be sure to use the centering jig when removing and installing the rear wiper motor assembly (for Glass Hatch Type). Failure to do so will result in a change of the location of the axis of the rear wiper motor assembly (for Glass Hatch Type), causing the wiping angle to change.
    • After installing the rear wiper motor assembly (for Glass Hatch Type), do not open the glass hatch before installing the rear wiper link pivot.
    • If the rear wiper motor assembly is removed without using the centering jig, the rear wiper motor assembly must be replaced with a new one.
  2. REMOVE BACK WINDOW UPPER TRIM PANEL ASSEMBLY  (See DISASSEMBLY )
  3. REMOVE BACK DOOR TRIM COVER LH (w/o Power Back Door)  (See DISASSEMBLY )
  4. REMOVE BACK DOOR SERVICE HOLE COVER LH (w/ Power Back Door)  (See DISASSEMBLY )
  5. DISCONNECT POWER BACK DOOR ROD (w/ Power Back Door)  (See DISASSEMBLY )
  6. REMOVE BACK DOOR TRIM COVER LH (w/ Power Back Door)  (See DISASSEMBLY )
  7. REMOVE BACK DOOR TRIM COVER RH  (See DISASSEMBLY )
  8. REMOVE BACK DOOR LOCK COVER (for Glass Hatch Type)  (See DISASSEMBLY )
  9. REMOVE ASSIST STRAP HOLE COVER  (See DISASSEMBLY )
  10. REMOVE ASSIST STRAP ASSEMBLY  (See DISASSEMBLY )
  11. REMOVE BACK DOOR TRIM PANEL ASSEMBLY  (See DISASSEMBLY )
  12. REMOVE REAR WIPER SHAFT COVER (for Glass Hatch Type)  (See REMOVAL )
  13. REMOVE REAR WIPER ARM HEAD CAP  (See REMOVAL )
  14. REMOVE REAR WIPER ARM AND BLADE ASSEMBLY  (See REMOVAL )
  15. REMOVE REAR WIPER LINK CAP (for Glass Hatch Type)  (See REMOVAL )
  16. REMOVE REAR WIPER MOTOR GROMMET (for Fixed Glass Type)  (See REMOVAL )
  17. REMOVE REAR WIPER LINK PIVOT (for Glass Hatch Type)  (See REMOVAL )
  18. REMOVE REAR WIPER MOTOR ASSEMBLY (for Fixed Glass Type)  (See REMOVAL )
  19. REMOVE REAR WIPER MOTOR ASSEMBLY (for Glass Hatch Type)  (See REMOVAL )
  20. REMOVE BACK DOOR GLASS GUIDE BRACKET SUB-ASSEMBLY (for Fixed Glass Type)  (See DISASSEMBLY )
  21. REMOVE REAR SPOILER SUB-ASSEMBLY  (See REMOVAL )
  22. REMOVE CENTER STOP LIGHT ASSEMBLY 
    1. Remove the 2 screws.
    2. Disconnect the center stop light assembly from the rear spoiler sub-assembly.
    3. Disconnect the connector and remove the center stop light assembly.
    Fig 1: Identifying Center Stop Light Assembly Screws
    G05419846Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals