LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2009 >> Avalon XLS >> Repair and Diagnosis >> Accessories & Equipment >> Gauges & Instrument Panels >> Meter >> Meter / Gauge System >> Data List / Active Test

Data List / Active Test

  1. Data List 

    Using Techstream to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.

    1. Warm up the engine.
    2. Ignition switch off.
    3. Connect Techstream to the DLC3.
    4. Ignition switch on (IG).
    5. Turn the tester on.
    6. Enter the following menus:
      1. for Combination Meter: Body Electrical / Combination Meter / Data List.
      2. for ABS/TRAC/VSC: Chassis / ABS/VSC/TRAC / Data List.
      3. for Engine and ECT: Powertrain / Engine and ECT / Data List.
      4. for Main Body: Body Electrical / Main Body / Data List.
    7. Check values by referring to the table below.

      Combination Meter: 

      DATA LIST - COMBINATION METER

      Tester Display Measurement Item/Range Normal Condition
      Tail Cancel SW Tail cancel switch is OFF/ON OFF: Turn the light control rheostat knob is not fully downwards
      ON: Turn the light control rheostat knob fully upwards
      ODO/TRIP Change SW ODO/TRIP switch is OFF/ON OFF: Switch is released
      ON: Switch is pushed
      Vehicle Speed Meter Vehicle speed/Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) Almost same as actual vehicle speed (When driving)
      Engine Rpm Engine speed/Min.: 0 rpm, Max.: 12750 rpm Almost same at the meter rpm (When engine is running)
      Coolant Temperature Engine coolant temperature: 0°C (32°F) to 127.5°C (261.5°F) After warming up: 80 to 95°C (176 to 203°F)
      Fuel Input Fuel input signal Min.: 0, Max. 127.5 Fuel gauge indicates (E): 7.5 (L)
      Fuel gauge indicates (1/2): 35.0 (L)
      Fuel gauge indicates (F): 62.9 (L)
      Light Control Rheostat Light Control Rheostat/Min.: 0%, Max.: 100% Light control rheostat switch is Dark (0%) → Bright (100%)
      Key Remind Sound The cycle of the key reminder warning buzzer is displayed The cycle of the key reminder warning buzzer is Large, Medium, Small
      Key Remind Volume The volume of the key reminder warning buzzer is displayed The volume of the key reminder warning buzzer is Fast, Normal, Slow

      ABS/VSC/TRAC: 

      DATA LIST - ABS/VSC/TRAC

      Tester Display Measurement Item/Range Normal Condition
      FR/FL/RR/RL Wheel Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost same as actual vehicle speed (When driving)
      Vehicle Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost same as actual vehicle speed (When driving)

      Engine and ECT: 

      DATA LIST - ENGINE AND ECT

      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      Engine Speed Vehicle speed/Min.: 0 rpm, Max.: 16383.75 rpm Almost same as actual engine speed (When engine running) -
      Coolant Temp Engine coolant temperature: Min.: -40°C (-40°F), Max: 140°C (284°F) 80 to 100°C (176 to 212°F): After warming up
      • If -40°C (-40°F): sensor circuit open
      • If 140°C (284°F) or more: sensor circuit shorted

      Main Body: 

      ACTIVE TEST DETAIL - MAIN BODY

      Tester Display Test Part Control Range
      Illumination Rate Info Illumination rate information / 0 ms. to 99.99 ms. 0.8 to 22.0 ms. (Value is output according to outside illuminance)

      SRS Airbag: 

      DATA LIST - SRS AIRBAG

      Tester Display Measurement Item/Range Normal Condition
      Passenger Classification Front passenger condition CHILD: Front passenger seat is occupied by a child NONE: Front passenger seat is not occupied
      Driver Buckle SW Driver side buckle switch ON: Driver side seat belt is fastened OFF: Driver side seat belt is unfastened
      Passenger Buckle SW Front passenger side buckle switch ON: Front passenger side seat belt is fastened OFF: Front passenger side seat belt is unfastened

      Combination Switch: 

      DATA LIST - COMBINATION SWITCH

      Tester Display Measurement Item/Range Normal Condition
      Dimmer HI switch Dimmer HI switch ON: Dimmer switch position is HI
      OFF: Dimmer switch position is not HI
      Light HEAD switch Light HEAD switch ON: Dimmer switch position is HEAD
      OFF: Dimmer switch position is not HEAD
      Light TAIL switch Light TAIL switch ON: Dimmer switch position is TAIL
      OFF: Dimmer switch position is not TAIL
      Turn left switch Turn left switch ON: Turn left switch is ON
      OFF: Turn left switch is OFF
      Turn right switch Turn right switch ON: Turn right switch is ON
      OFF: Turn right switch is OFF

      Body No.5: 

      DATA LIST - BODY NO 5

      Tester Display Measurement Item/Range Normal Condition
      Washer Level Switch Washer Level Switch ON: Washer level switch is ON
      OFF: Washer level switch is OFF
      Oil Level Sensor Oil Level Sensor ON: Oil level sensor is ON
      OFF: Oil level sensor is OFF
      Oil Pressure Switch Oil Pressure Switch ON: Oil pressure switch is ON
      OFF: Oil pressure switch is OFF
  2. Active Test 

    Using Techstream to perform Active Tests allows the relay, actuator, and other items to operate without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Test early in troubleshooting is one way to save diagnostic time. Data List information can be display while performing Active Test.

    1. Connect Techstream to the DLC3.
    2. Ignition switch on (IG).
    3. Turn the tester on.
    4. Enter the following menus: Body Electrical / Combination Meter / Active Test.
    5. Check the operation by referring to the table below.

      Combination Meter: 

      ACTIVE TEST DETAIL - COMBINATION METER

      Tester Display Test Part Control Range Diagnostic Note
      Speed Meter Operation Speedometer 0, 40, 80, 120 mph ((1)) -
      0, 40, 80, 120, 160, 200, 240 km/h ((2)) -
      Tacho Meter Operation Tachometer 0,1000, 2000, 3000, 4000, 5000, 6000, 7000 (rpm) -
      Fuel Meter Operation Fuel receiver gauge EMPTY, 1/2, FULL Confirm that the vehicle is stopped, engine idling
      Water Temperature Meter Operation Engine coolant temperature receiver gauge Low, Normal, High Confirm that the vehicle is stopped, engine idling
      A/T Indicator Operation A/T shift indicator light A/T shift indicator light D, N, R, P is OFF/ON Confirm that the vehicle is stopped, engine idling
      Front Passenger Side Seat Belt Front passenger side seat belt warning light Front passenger side seat belt warning light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Driver Side Seat Belt Driver side seat belt warning light Driver side seat belt warning light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp ABS ABS warning light ABS warning light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Charge Charge warning light Charge warning light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Slip Slip indicator light Slip indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Beam Hi-beam indicator light Hi-beam indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Head ((1)) Head indicator light Head indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Tail ((2)) Tail indicator light Tail indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Door Open door warning light Open door warning light is OFF/ ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Washer Washer indicator light Washer level warning light is OFF/ ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Fuel Low fuel warning light Fuel level warning light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Tire Pressure Warning System ((3)) Tire pressure warning light Tire pressure warning light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Oil Oil pressure warning light Oil pressure warning light is OFF/ ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Cruise Cruise indicator light Cruise indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp Brake Brake warning light Brake warning light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Oil Maintenance Oil replacement reminder light Oil replacement reminder light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp VSC VSC indicator light VSC indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. ODO/TRIP Display ODO/TRIP display ODO/TRIP display is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Laser Cruise Display Laser cruise display Laser cruise display is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp L-Cruise Check Laser cruise check display Laser cruise check display is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Lamp L-Cruise Ready Laser cruise ready display Laser cruise ready display is OFF/ ON Confirm that the vehicle is stopped, engine idling
      Key Remained Buzzer Key reminder warning buzzer Key reminder warning buzzer is OFF/ON Confirm that the vehicle is stopped, engine idling
      Seat Belt Buzzer Seat belt warning buzzer Seat belt warning buzzer is OFF/ ON Confirm that the vehicle is stopped, engine idling
      Sports Shift Reject Buzzer Sports shift reject buzzer Sports shift reject buzzer is OFF/ ON Confirm that the vehicle is stopped, engine idling
      Speed Buzzer Speed warning buzzer Speed warning buzzer is OFF/ON Confirm that the vehicle is stopped, engine idling
      Warning Buzzer Warning buzzer Warning buzzer is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. A/T Shift LCD A/T shift indicator A/T shift indicator is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. SMART KEY Key indicator light Key indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling
      Indicat. Set Set indicator light Set indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling
      (1) U.S.A.
      (2) Except U.S.A.
      (3) with Tire Pressure Warning System
scientia non olet · About LEMON Manuals