LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2008 >> Highlander Base, FWD >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> (Door / Hatch) (Except Hybrid) >> Power Back Door Drive Unit >> Removal

Power Back Door Drive Unit: Removal

  1. REMOVE REAR DOOR SCUFF PLATE LH  (See REMOVAL )
  2. DISCONNECT REAR DOOR OPENING TRIM WEATHERSTRIP LH 
  3. REMOVE DECK BOARD ASSEMBLY  (See REMOVAL )
  4. REMOVE NO. 3 DECK BOARD SUB-ASSEMBLY  (See REMOVAL )
  5. REMOVE NO. 2 DECK BOARD SUB-ASSEMBLY  (See REMOVAL )
  6. REMOVE TONNEAU COVER ASSEMBLY (w/ Tonneau Cover)  (See REMOVAL )
  7. REMOVE REAR NO. 1 FLOOR BOARD (w/o Rear No. 2 Seat)  (See REMOVAL )
  8. REMOVE REAR SEAT SIDE COVER LH (w/ Rear No. 2 Seat)  (See REMOVAL )
  9. REMOVE DECK SIDE TRIM BOX LH  (See REMOVAL )
  10. REMOVE REAR SEAT SIDE COVER RH (w/ Rear No. 2 Seat)  (See REMOVAL )
  11. REMOVE JACK CARRIER SUPPORT 
  12. REMOVE JACK CARRIER CUSHION  (See REMOVAL )
  13. REMOVE JACK ASSEMBLY  (See REMOVAL )
  14. REMOVE JACK CARRIER ASSEMBLY  (See REMOVAL )
  15. REMOVE DECK SIDE TRIM BOX RH  (See REMOVAL )
  16. REMOVE DECK FLOOR BOARD ASSEMBLY (w/o Rear No. 2 Seat)  (See REMOVAL )
  17. REMOVE REAR MAT  (See REMOVAL )
  18. REMOVE DECK FLOOR BOARD ASSEMBLY (w/ Rear No. 2 Seat)  (See REMOVAL )
  19. REMOVE REAR DECK FLOOR BOX (w/o Rear No. 2 Seat)  (See REMOVAL )
  20. REMOVE REAR NO. 2 SEAT INNER BELT ASSEMBLY (w/ Rear No. 2 Seat)  (See REMOVAL )
  21. DISCONNECT REAR SEAT LAP TYPE BELT ASSEMBLY LH (w/ Rear No. 2 Seat)  (See REMOVAL )
  22. DISCONNECT REAR SEAT LAP TYPE BELT ASSEMBLY RH (w/ Rear No. 2 Seat)  (See REMOVAL )
  23. REMOVE REAR NO. 2 SEAT ASSEMBLY (w/ Rear No. 2 Seat)  (See REMOVAL )
  24. REMOVE REAR FLOOR FINISH PLATE  (See REMOVAL )
  25. REMOVE DECK SIDE TRIM COVER LH  (See REMOVAL )
  26. REMOVE DECK SIDE TRIM LH  (See REMOVAL )
  27. REMOVE SIDE TRIM COVER LH (w/o Rear Seat Entertainment System)  (See REMOVAL )
  28. REMOVE POWER OUTLET SOCKET BEZEL (w/ Rear Seat Entertainment System)  (See REMOVAL )
  29. REMOVE REAR COMBINATION LIGHT SERVICE COVER LH  (See REMOVAL )
  30. REMOVE REAR POWER POINT SOCKET ASSEMBLY  (See REMOVAL )
  31. REMOVE REAR POWER OUTLET SOCKET COVER  (See REMOVAL )
  32. REMOVE REAR DECK TRIM COVER (w/o Remote Folding Function)  (See REMOVAL )
  33. REMOVE RECLINING REMOTE CONTROL LEVER BEZEL LH (w/ Remote Folding Function)  (See REMOVAL )
  34. REMOVE ROPE HOOK ASSEMBLY  (See REMOVAL )
  35. REMOVE NO. 2 DECK SIDE TRIM HOOK  (See REMOVAL )
  36. REMOVE FRONT DECK SIDE TRIM COVER LH  (See REMOVAL )
  37. DISCONNECT REAR NO. 1 SEAT OUTER BELT ASSEMBLY LH  (See REMOVAL )
  38. REMOVE DECK TRIM SIDE PANEL ASSEMBLY LH  (See REMOVAL )
  39. REMOVE ROOF SIDE INNER GARNISH ASSEMBLY LH  (See REMOVAL )
  40. REMOVE BACK WINDOW UPPER TRIM PANEL ASSEMBLY  (See DISASSEMBLY  )
  41. REMOVE BACK DOOR SERVICE HOLE COVER LH  (See DISASSEMBLY  )
  42. REMOVE BACK DOOR MOTOR UNIT 
    1. Disconnect the power back door rod and remove the back door stay plate.
      Fig 1: Identifying Power Back Door Rod
      G05422271Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Disconnect the connector.
    3. Disengage the clip.
    4. Remove the 4 bolts and back door motor unit.
      Fig 2: Identifying Back Door Motor Unit Bolts
      G05422343Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals