Data List/Active Test
- DATA LIST
HINT:
According to the DATA LIST displayed by the hand-held tester, you can read the value of the switch, sensor, actuator and so on without parts removal. Reading the DATA LIST as the first step of troubleshooting is one of the methods to shorten labor time.
- Connect the hand-held tester to the DLC3.
- Turn the ignition switch ON.
- According to the display on tester, read the "DATA LIST".
DATA LIST - REFERENCE TABLEItem Measurement Item / Range (Display) Normal Condition Diagnostic Note ABS MOT RELAY ABS motor relay / ON or OFF ON: Motor relay ON
OFF: Motor relay OFF- SOL RELAY Solenoid relay / ON or OFF ON: Solenoid relay ON
OFF: Solenoid relay OFF- STOP LIGHT SW Stop lamp switch / ON or OFF ON: Brake pedal depressed
OFF: Brake pedal released- PKB SW Parking brake switch / ON or OFF ON: Parking brake applied
OFF: Parking brake released- VEHICLE SPD Maximum wheel speed sensor reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual vehicle speed Speed indicated on speedometer ABS OPERT FR ABS operation (FR) / BEFORE or OPERATE BEFORE: No ABS operation (FR)
OPERATE: During ABS operation (FR)Similar speed as indicated on speedometer ABS OPERT FL ABS operation (FL) / BEFORE or OPERATE BEFORE: No ABS operation (FL)
OPERATE: During ABS operation (FL)Similar speed as indicated on speedometer ABS OPERT RR ABS operation (RR) / BEFORE or OPERATE BEFORE: No ABS operation (RR)
OPERATE: During ABS operation (RR)Similar speed as indicated on speedometer ABS OPERT RL ABS operation (RL) / BEFORE or OPERATE BEFORE: No ABS operation (RL)
OPERATE: During ABS operation (RL)Similar speed as indicated on speedometer WHEEL SPD FR Wheel speed sensor (FR) reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual wheel speed Speed indicated on speedometer WHEEL SPD FL Wheel speed sensor (FL) reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual wheel speed Speed indicated on speedometer WHEEL SPD RR Wheel speed sensor (RR) reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual wheel speed Speed indicated on speedometer WHEEL SPD RL Wheel speed sensor (RL) reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual wheel speed Speed indicated on speedometer IG VOLTAGE ECU power supply voltage / NORMAL or TOO LOW NORMAL: 9.5 V or over TOO LOW: Below 9.5 V - SFRR ABS solenoid (SFRR) ON / OFF ON: Operate
OFF: Not operate- SFRH ABS solenoid (SFRH) ON / OFF ON: Operate
OFF: Not operate- SFLR ABS solenoid (SFLR) ON / OFF ON: Operate
OFF: Not operate- SFLH ABS solenoid (SFLH) ON / OFF ON: Operate
OFF: Not operate- SRRR (SRR) ABS solenoid (SRRR (SRR)) ON / OFF ON: Operate
OFF: Not operate- SRRH (SRH) ABS solenoid (SRRH (SRH)) ON / OFF ON: Operate
OFF: Not operate- SRLR ABS solenoid (SRLR) ON / OFF ON: Operate
OFF: Not operate- SRLH ABS solenoid (SRLH) ON / OFF ON: Operate
OFF: Not operate- AIR BLD SUPPORT Air bleed support / SUPPORT or NOT SUP Supported - TEST MODE Test mode / NORMAL or TEST NORMAL: Normal mode
TEST: During test mode- #CODES Number of DTC recorded / min.: 0, max.: 255 Min.: 0, max.: 19 - SPD SEN FR FR speed sensor open detection / OPEN or NORMAL OPEN: Momentary interruption - SPD SEN FL FL speed sensor open detection / OPEN or NORMAL OPEN: Momentary interruption - SPD SEN RR RR speed sensor open detection / OPEN or NORMAL OPEN: Momentary interruption - SPD SEN RL RL speed sensor open detection / OPEN or NORMAL OPEN: Momentary interruption - - ACTIVE TEST
HINT:
Performing the ACTIVE TEST using the hand-held tester allows the relay, VSV, actuator and so on to operate without parts removal. Performing the ACTIVE TEST as the first step of troubleshooting is one of the methods to shorten labor time.
It is possible to display the DATA LIST during the ACTIVE TEST.
- Connect the hand-held tester to the DLC3.
- Turn the ignition switch ON.
- According to the display on the tester, perform the "ACTIVE TEST".
ACTIVE TEST - REFERENCE TABLEItem Vehicle Condition / Test Details Diagnostic Note SFRR Turns ABS solenoid (SFRR) ON / OFF Operation of solenoid (clicking sound) can be heard SFRH Turns ABS solenoid (SFRH) ON / OFF Operation of solenoid (clicking sound) can be heard SFLR Turns ABS solenoid (SFLR) ON / OFF Operation of solenoid (clicking sound) can be heard SFLH Turns ABS solenoid (SFLH) ON / OFF Operation of solenoid (clicking sound) can be heard SRRR Turns ABS solenoid (SRRR) ON / OFF Operation of solenoid (clicking sound) can be heard SRRH Turns ABS solenoid (SRRH) ON / OFF Operation of solenoid (clicking sound) can be heard SRLR Turns ABS solenoid (SRLR) ON / OFF Operation of solenoid (clicking sound) can be heard SRLH Turns ABS solenoid (SRLH) ON / OFF Operation of solenoid (clicking sound) can be heard SFRR & SFRH Turns ABS solenoid SFRR & SFRH ON / OFF Operation of solenoid (clicking sound) can be heard SFLR & SFLH Turns ABS solenoid SFLR & SFLH ON / OFF Operation of solenoid (clicking sound) can be heard SRH & SRR Turns ABS solenoid SRH & SRR ON / OFF Operation of solenoid (clicking sound) can be heard SRLR & SRLH Turns ABS solenoid SRLR & SRLH ON / OFF Operation of solenoid (clicking sound) can be heard SFRH & SFLH Turns ABS solenoid SFRH & SFLH ON / OFF Operation of solenoid (clicking sound) can be heard SOL RELAY Turns ABS solenoid relay ON / OFF Operation of solenoid (clicking sound) can be heard ABS MOT RELAY Turns ABS motor relay ON / OFF Operation of motor can be heard ABS WARN LIGHT Turns ABS warning light ON / OFF Observe combination meter BRAKE WRN LIGHT Turns BRAKE warning light ON / OFF Observe combination meter